Ampcontrol OCS - Page 6

Ampcontrol Pty Ltd – ABN 28 000 915 542
OCS USER MANUAL
MAG-182 Version 5 – FEB/2020
Uncontrolled Copy - Refer to Ampcontrol Website for Latest Version
Page 6 of 72
APPROVED FOR EXTERNAL DISTRIBUTION
– PROPERTY OF AMPCONTROL PTY LTD
– NOT TO BE REPRODUCED IN PART
TABLE OF FIGURES
Figure 3.1: Ampcontrol Outlet Cassette System (OCS) .......................................................................... 11
Figure 3.2: Ampcontrol Fixed Cassette System (FCS) ............................................................................ 12
Figure 4.1: 2-Way OCS Dimensions (Pictured with 2 Cassettes Installed) .............................................. 16
Figure 4.2: 3-Way OCS Dimensions (Pictured with 3 Cassettes Installed) .............................................. 16
Figure 4.3: FCS Dimensions (Pictured with 5 Cassettes Installed) ......................................................... 17
Figure 4.4: Remote Termination Unit (RTX) ........................................................................................... 18
Figure 6.1: Actuator position within chassis ............................................................................................ 29
TABLE OF TABLES
Table 1: Definitions ................................................................................................................................... 7
Table 2: Event Log Entry Types ............................................................................................................. 23
Table 3: Outlet Parameter Descriptions .................................................................................................. 26
Table 4: Load Parameter Descriptions ................................................................................................... 27
Table 5: Protection Element - Earth Leakage Trip Characteristics .......................................................... 30
Table 6: Protection Element - Earth Leakage CT Failure Trip Characteristics ........................................ 31
Table 7: Protection Element – Residual Voltage Trip Characteristics ..................................................... 31
Table 8 Protection Element - Earth Continuity Series Trip Characteristics .............................................. 33
Table 9: Protection Element - Earth Continuity Shunt Trip Characteristics .............................................. 33
Table 10: Protection Element - Earth Continuity Pilot Interlock Trip Characteristics ................................ 34
Table 11: Protection Element - Earth Fault Lockout (EFLO) Trip Characteristics .................................... 35
Table 12: Protection Element – High Voltage Insulation Test Characteristics ......................................... 35
Table 13: Protection Element – Voltage Detection (Loss of Vacuum) Trip Characteristics ...................... 36
Table 14: Protection Element – Frozen Contactor Trip Characteristics ................................................... 37
Table 15: Protection Element – Contactor Close Fail Trip Characteristics .............................................. 37
Table 16: Protection Element – External Open Trip Characteristics ........................................................ 38
Table 17: Protection Element – Coil Voltage Detection Trip Characteristics ........................................... 38
Table 18: Protection Element – Over Current Trip Characteristics .......................................................... 39
Table 19: Protection Element – Motor Overload Trip Characteristics ...................................................... 41
Table 20: Protection Element – Short Circuit Trip Characteristics ........................................................... 44
Table 21: Protection Element – Current Balance Trip Characteristics ..................................................... 45
Table 22: Protection Element – Under Current Trip Characteristics ........................................................ 46
Table 23: Protection Element – Under Voltage Trip Characteristics ........................................................ 46