andrews MAXXflo - Parts List

MAXXo Water Heater
4242
MAXXFLO SPARES LIST
ITEM DESCRIPTION Part No.
2 Sensor Dip Tube 200 Litre c/w Hatch 5140790
3 Sensor Dip Tube 300 Litre c/w Hatch 5140791
4 Air Vent ½” SMC 15 5141513
5 Storage Vessel – 200 Litre E651
6 Storage Vessel – 300 Litre E652
7 Brass Tee 22 x 22 x ½” 5141514
8 Tank Temperature Sensor & Lead E664
9 Tundish C384
10 Andrews Dome Label E856
12 Condensate Trap E211
13 MAXXo Dome Label E927
14 Front Cover (pump facing rear) pre-serial no. 071201 E918
15 Front Cover (pump facing front) from serial no. 071201 E919
16 Drain Cover Plate (200 Litre vessel) from serial no. 071906 E935
17 Drain Cover Plate (300 Litre vessel) from serial no. 071906 E936
18 Switch On/Off E665
19 Master & Terminal Panel Wiring Loom E858
20 Slave Board E661
21 Master Control Board E853
22 Wiring Loom 30/200 & 30/300 models E849
23 Wiring Loom 60kW models E850
24 Wiring Loom 90kW models E851
25 Wiring Loom 120kW models E852
26 Hot surface Ignitor Service Set c/w gasket E657
27 Ionisation Electrode Service Set c/w gasket E655
28 Hot surface Ignitor Gasket 5141517
29 Gasket for Ionisation Electrode 5141518
30 Heat Exchanger Brass Outlet Bracket E937
31 Temperature Flow Surface Sensor E663
32 Heat Exchanger Outlet Fitting & Seals E917
33 Heat Exchanger 15mm Outlet O-ring Seals E654
35 Heat Exchanger Top Lid Insulation G025
36 Heat Exchanger Top Lid Body Seal G024
37 Heat Exchanger E656
38 Heat Exchanger Inlet/Outlet Pipe Seals x 2 5141515
39 Burner 5141516
40 Brass Flow Restrictor (after & inc serial no. 1105004468) 5141512
41 Pump Elbow & Vent Union (used with composite pump after & inc. serial no.071201) E921
42 Fan Gasket E846
43 Burner Gasket E932
44 Pump Elbow & Vent Union (used with bronze pump after & inc. serial no.071201) E847
45 Pump Gasket E964
46 Vapour Tray Gasket E931
47 Circlip – Stainless Steel 15mm E963
48 Composite Body Primary Pump (after and inc. serial no.071201) E920
49 Bronze Body Primary Pump (pre-serial no.071201) E660
50 Non Return Valve (pre-serial no.1105004468) E930
51 Burner Bafes Service Set E933
52 Fan Assembly c/w Gasket E658
53 Heat Exchanger Condensing Tray G179
54 Gas Valve Seal E845
55 Gas Valve Assembly E659
56 Plastic Black 16mm x
1
⁄2” BSP Male Elbow E968
57 Air Inlet 125mm CWH30/CWH60 5141520
58 Flue/Air Seal Set CWH30 5141632
59 Flue Pipe 60mm CWH30 5140795
60 Flue/Air Seal Set CWH60 5141633
61 Flue Pipe 80mm CWH60 5140796
62 Blanking Plug for Flue Connector 5141522
63 Flue Gas Collector (Lower) CWH30/CWH60/CWH90 E967
64 Air Inlet 200mm CWH90/CWH120 5141523
65 Flue/Air Seal Set CWH90 5141634
66 Flue Gas Collector (Upper) CWH90 E965
67 Flue Pipe CWH90/CWH120 5140794
68 Condensate Tube Grommet 15mm E857
69 Flue/Air Seal Set CWH120 5141635
70 Flue Gas Collector (Upper) CWH120 E966
71 O-ring for Cold Feed dip Tube E928
72 O-ring for Return dip Tube E929
73 Flow Dip Tube Assembly 5141519
74 Set of 16 no. M10 Stainless Steel Bolts & Washers E859
75 Top Plate Seal E653
76 Sensor Pocket Dip Tube – 200 Litre 5140792
77 Sensor Pocket Dip Tube – 300 Litre 5140793
78 Heat Exchanger Top Plate c/w Ceramic Board, Gasket & Fixings 7212717
79 Blue Tee 14mm x 14mm x 14mm E969
80 Blue Straight Connector
1
⁄2” x 14mm 5141636
81 Temperature & Pressure Relief Valve C380AWH
82 Combustion Plug 5142574
83 Hatch Seal 5142675
SECTION 8 - PARTS LIST