TABLE OF CONTENTS (CONTINUED)
Clean the Cabinet and Control Panel
and Power Supplies ..................................... 33
Monthly Maintenance—Patient ................... 34
Care for the Power Cartridge ....................... 34
Calibrating the Power Cartridge .................. 34
Patient Training Checklist ............................ 35
Annual Maintenance—Provider ........................ 36
Introduction ..................................................... 36
Annual Maintenance Check List .................. 36
Checking and Replacing the Power Cartridge
.................................................................... 36
Eclipse 5 Monthly Run-Time Cycle .............. 36
Annual Maintenance Procedures .................... 37
Removing the Unit Cover ............................ 37
Remove and Replace 9 Volt Battery ........... 41
Remove and Replace HEPA Filter ............... 42
Internal Filters ............................................. 42
Remove and Replace the Compressor
Intake Filter .............................................. 44
Reinstalling or Replacing the Unit Cover ..... 46
Test Procedures .............................................. 47
Purity and Flow Rate Test
Procedure - Preferred Method ................. 47
Purity and Flow Rate Test Procedure-
Alternate Method ..................................... 47
Assembly and Alarm Verification Tests ........ 48
Record Hours of Operation & Software
Version ........................................................ 49
Electrical Safety Test ..................................... 50
Cleaning the Eclipse 5 ................................. 50
Provider Service and Maintenance Record ..... 51
Shipping and Transporting the Eclipse 5 ..... 52
Storing the Eclipse 5 ................................... 52
Discarding ................................................... 52
Troubleshooting, Service, and
Repair Procedures ........................................ 53
System Troubleshooting and Alarms ............... 54
Alarm Conditions and Alarm Codes ................ 57
Malfunction Codes .......................................... 59
System Schematics and Diagrams ................. 60
Oxygen Circuit ................................................ 62
Remove and Replace the ATF Module ........ 62
Remove and Replace the Product Tank
Assembly (PN 4378-SEQ) Eclipse 5 ....... 66
Electronics ...................................................... 69
Remove and Replace the Control
Board Assembly ..................................... 69
Remove and Replace the Buzzer Wire Harness
.................................................................... 71
Control Board Connector Diagram .............. 72
Remove and Replace the Power Manager
Printed Circuit Board ............................... 73
Compressor .................................................... 77
Remove and Replace the Compressor Box 77
Maintenance and Replacement Parts ............. 81
Preventative Maintenance Parts ................. 81
Replacement Parts List ............................... 81
Optional Accessories .................................. 82
CAIRE Inc. Customer Service Contact
Information .................................................... 83
3
To Next Page
Loading...
