Carrier ASPAX1CCA015 User Manual

1
Table of Contents
15 kW Generator
Introduction ........................Inside Front Cover
Read This Manual Thoroughly ........................ IFC
Contents .......................................................... IFC
Operation and Maintenance ............................ IFC
How to Obtain Service ..................................... IFC
Safety Rules ........................................................2
Standards Index ..................................................3
Section 1 – General Information ...................4
1.1 Unpacking/Inspection .................................... 4
1.2 Location ........................................................ 4
1.3 Protection Systems ........................................ 4
1.4 System Set LED ............................................4
1.5 The Generator ...............................................5
1.6 Specifications ................................................ 6
1.6.1 Generator ........................................... 6
1.6.2 Engine ................................................ 6
1.7 Fuel Requirements and Recommendations ... 6
1.8 Fuel Consumption ......................................... 6
1.9 Reconfiguring the Fuel System ...................... 7
1.9.1 15 kW, 990cc Engines ........................7
1.10 Location ........................................................ 7
1.10.1 Generator ...........................................7
1.10.2 Transfer Switch ..................................8
1.11 Battery Installation ........................................ 8
1.12 The Battery ...................................................8
Section 2 – Post Installation Start-up
and Adjustments .........................9
2.1 Before Initial Start-up .................................... 9
2.2 Check Transfer Switch Operation .................9
2.3 Electrical Checks .......................................... 9
2.4 Generator Tests Under Load ....................... 10
2.5 Checking Automatic Operation ....................10
2.6 Adjusting the Regulator (Natural Gas Only) .. 11
2.7 Engine Governor Adjustment ......................12
2.7.1 15 kW Units .....................................12
2.8 Voltage Regulator Adjustment ......................12
Section 3 – Operation ....................................12
3.1 Break-in Procedure ..................................... 12
3.2 Using the Auto/Off/Manual Switch ............... 13
3.2.1 “Auto” Position .................................. 13
3.2.2 “Off” Position.................................... 13
3.2.3 “Manual” Position .............................13
3.3 Automatic Transfer Operation ..................... 13
3.3.1 12 VDC Accessory Outlet ................. 13
3.3.2 120 VAC GFCI Outlet ....................... 14
3.4 Sequence of Automatic Operation ...............14
3.5 Manual Transfer Operation ......................... 14
3.5.1 Transfer to Generator
Power Source .....................................14
3.5.2 Transfer Back to Utility
Power Source .....................................15
3.6 Setting the Exercise Timer .......................... 15
3.7 Protection Systems ......................................15
3.7.1 Low Oil Pressure Switch .................. 15
3.7.2 High Temperature Switch ................. 15
3.7.3 Overcrank ........................................16
3.7.4 Overspeed ........................................ 16
Section 4 – Maintenance ...............................16
4.1 Fuses ........................................................... 16
4.2 Checking the Engine Oil Level .....................16
4.3 Changing the Engine Oil .............................. 16
4.3.1 Engine Oil Recommendations .......... 16
4.3.2 Oil Change Procedure .......................17
4.4 Changing the Oil Filter ................................17
4.5 Changing the Engine Air Cleaner ................. 17
4.5.1 15 kW Generators ............................17
4.6 Spark Plug(s) ..............................................17
4.7 Battery Maintenance ....................................18
4.8 Adjusting Valve Clearance ........................... 18
4.9 Cooling System ...........................................19
4.10 Attention After Submersion .........................19
4.11 Corrosion Protection ...................................19
4.11.1 Additional Corrosion Protection ....... 19
4.12 Out of Service Procedure ............................. 20
4.12.1 Removal From Service...................... 20
4.12.2 Return to Service .............................20
4.13 Service Schedule .........................................21
Section 5 – Troubleshooting ........................ 22
5.1 Troubleshooting Guide ................................ 22
Section 6 – Mounting Dimensions ............. 23
Section 7 – Electrical Data ........................... 24
Section 8 – Exploded Views and
Parts Lists ................................... 28
Section 9 – Warranty ..................................... 40

Carrier ASPAX1CCA015 Specifications

General

Brand	Carrier
Model	ASPAX1CCA015
Category	Inverter
Language	English