Carrier ASPAX1CCA015 - Page 31

ITEM PART NO. QTY. DESCRIPTION
1 0C6140 1 ASSEMBLY, ENCLOSURE BASE
0D1901 1 ASSEMBLY, ENCLOSURE BASE (7KW)
2 0C6735 2 SUPPORT, ROOF FOLDING
3 0F0063 1 ENCLOSURE, FRONT
4 0C7062 1 ENCLOSURE, EXHAUST SIDE
0C7062A 1 ENCLOSURE, EXHAUST SIDE (7KW)
5 0E8811 1 ENCLOSURE, SIDE & BACK
0E8811A 1 ENCLOSURE, SIDE & BACK (7KW)
6 0E9873 1 ENCLOSURE, ROOF
7 0C7065 1 PANEL, ALTERNATOR DIVIDER
0C7065A 1 PANEL, ALTERNATOR DIVIDER (7KW)
8 0C8101A 1 PANEL, MUFFLER BOX SIDE
0C8861 1 PANEL, MUFFLER BOX SIDE (7KW)
9 0C8101B 1 COVER, MUFFLER BOX
0C8862 1 COVER, MUFFLER BOX (7KW)
10 0C8283 1 GASKET, DOOR SEAL
11 0C8284A 1 FOAM, BACK ENCLOSURE
12 0C8
284B 1 FOAM, ROOF ENCLOSURE
13 0C8284C 1 FOAM, FRONT ENCLOSURE
14 0C8285 1 BRACKET, BATTERY SUPPORT
15 0C8899A 1 PAD, 24"X48" WITH MOUNTING HOLES
16 0D1128 1 PANEL, ENGINE DIVIDER
0D1128A 1 PANEL, ENGINE DIVIDER (7KW)
17 0E4244 1 BAFFLE, INTAKE
0D1605A 1 BAFFLE, INTAKE (7KW)
18 0D1606 1 HOUSING, FAN
0D5264 1 BAFFLE, EXHAUST (7KW)
19 0D1839 2 BRACKET, TOP SUPPORT
20 0D1840 2 BRACKET, BOTTOM SUPPORT
21 0D2425 1 DUCT, BASE AIR
22 0D2588 1 GASKET, FRONT DIVIDER
0D2588A 1 GASKET, FRONT DIVIDER (7KW)
23 0D2676 1 COVER, FRONT EXHAUST ENCLOSURE
24 0D2677 1 COVER, BACK EXHAUST ENCLOSURE
25 0D2979B 2 CLOTH, HARDWARE 266.7mm x 146mm
0D2979B 3 CLOTH, HARDWARE 266.7mm x 146mm (7KW)
26 0D2979C 1 CLOTH, HARDWARE 543mm x 146mm
27 0D297
9D 1 CLOTH, HARDWARE 266.7mm x 387.4mm
0D2979E 1 CLOTH, HARDWARE (7KW)
28 0E4245 1 FOAM, FRONT INTAKE BAFFLE
0D3058A 1 FOAM, FRONT INTAKE BAFFLE (7KW)
29 0E4245A 1 FOAM, TOP INTAKE BAFFLE
30 0E4245B 1 FOAM, BACK INTAKE BAFFLE
0D3058C 1 FOAM, BACK INTAKE BAFFLE (7KW)
31 0D3057D 1 FOAM, BACK ENCL. STRIP
32 0D3059A 1 FOAM, EXHAUST SIDE ENCLOSURE END
33 0D3059B 1 FOAM, EXHAUST SIDE ENCLOSURE FRONT
34 0D3059C 1 FOAM, EXHAUST FAN HOUSING
35 0D7176 24 WASHER, SELF LOCKING
22 WASHER, SELF LOCKING (7KW)
36 0D3059D 1 FOAM, FRONT EXHAUST ENCLSURE COVER
37 0D3059
E 1 FOAM, BACK EXHAUST ENCLOSURE COVER
38 0C7781A 2 DOOR, PAWL
39 0D3037 1 LATCH, QUARTER TURN LOCKING
40 0F0164 1 HINGE TYPE A WITH STUDS, PIN
41 0F0165 1 HINGE TYPE B WITH STUDS, PIN
42 0D3037A 1 LATCH, QUARTER TURN NON-LOCKING
43 0A2115 4 WASHER NYLON .250"
44 022097 1 WASHER LOCK M6-1/4"
46 0F0710 18 RIVET POP 0.125 X 0.337
ITEM PART NO. QTY. DESCRIPTION
47 047411 6 SCREW HHC M6-1.0 X 16 G8.8
047411 4 SCREW HHC M6-1.0 X 16 G8.8 (7KW)
48 043116 5 SCREW HHC M6-1.0 X 12 G8.8
043116 6 SCREW HHC M6-1.0 X 12 G8.8 (7KW)
49 0D3700 26 NUT, LOCKING FLANGE M6-1.0
0D3700 24 NUT, LOCKING FLANGE M6-1.0 (7KW)
50 0D4662 11 SCREW HHTT M8-1.2 X 20 BP
51 090388 36 SCREW TAPTITE M6-1.0 X 12 BP
24 SCREW TAPTITE M6-1.0 X 12 BP (7KW)
52 092120 2 NUT LOCK TRIC M6 X 1.0 Y/ZNC
54 0D3167 1 GASKET, BATTERY SUPPORT BRACKET
55 0A3328 1 PLUG, PLASTIC 0.593
56 055414 1 LUG SLDLSS #2-#8X17/64 CU
57 092079 1 SCREW TAPTITE M6-1.0X25 BP
58 0A1658 2 L/WASH SPECIAL ¼
59 0C2
937 1 BRACKET, BATTERY HOLD DOWN (7KW)
60 086729 1 CONTACTOR, STARTER (7KW)
61 0388040AJ0 1 CABLE, #6 RED BATTERY 38.5"
62 022127 2 NUT HEX 1/4-20 STEEL (7KW)
63 022129 6 WASHER LOCK 5/16
022129 7 WASHER LOCK 5/16 (7KW)
64 074908 8 SCREW TAPTITE M5-0.8 X 10 BP
65 0D2346 1 HARNESS, ENGINE
0D2345 1 HARNESS, ENGINE (7KW)
66 023484F 1 BUSHING, SNAP SB-1000-12
67 022142 1 SCREW HHC 5/16-18 X 3/4 G5 (7KW)
68 0A7836 2 RIVET,1/8" X 0.126" - 0.375" LSH POP
69 0A8475 2 L/WASH SPECIAL #10
70 0912970069 1 ASSEMBLY, ROOF / DOOR GROUND WIRE
71 09129
70070 2 ASSEMBLY, ROOF / DOOR GROUND WIRE
72 055450 2 PLUG PLASTIC 1.375
73 0E5968 11 GASKET, EXTRUDED TRIM
74 0D3701 1 PLATE, "HOT"
75 0D3472 1 GROMMET 2.75 X 1/16
76 0C8742 1 EXTERNAL CONNECTION BOX
77 0C8911 1 POWER BLOCK
78 0D8442 1 HARNESS GENERATOR TO EXT CONN BOX
0D8652 1 HARNESS GENERATOR TO EXT
CONNECTION BOX (7KW)
79 036937 2 SCREW PPHM #10-32 X 1
80 022152 5 WASHER LOCK #10
81 051713 2 WASHER FLAT M5
82 022158 5 NUT HEX #10-32 STEEL
83 0D3031 1 FUEL LINE, 3/4"OUTDOOR (NOT SHOWN)
84 026850 1 WASHER SHAKPROOF EXT 1/4 STEEL
85 04981
3 1 NUT HEX M6-1.0 G8 YELLOW CHROME
86 0F0164A 1 HINGE TYPE A WITH STUDS, SOCKET
87 0F0165A 1 HINGE TYPE B WITH STUDS, SOCKET
89 0E2874 1 SCREW HHTR 1/4-20 X 3/4
90 043107 4 SCREW HHC M8-1.25 X 25
91 022145 10 WASHER FLAT 5/16
92 045771 4 NUT HEX M8-1.25
93 0C3906 2 SELF-ALIGN SCREW M6 HH
94 0E4321 1 PANEL, EXHAUST ALIGNMENT
95 0E1330A 1 GROMMET, 38.1 CROSS SLIT WITH HOLE
96 0E9692 1 BRACKET, REGULATOR MOUNTING
97 042907 2 SCREW HHC M8-1.25 X 16mm
98 0F5241 1 PLATE, COVER
99 0F594
3 1 GASKET, COVER
Section 8 — Exploded Views and Parts Lists
15 kW Generator
Enclosure – Drawing No. 0F0080-C
29