2–15 62-11637
2.7 ENGINE DATA
2.8 COMPRESSOR DATA
Unit Specification
Engine Model V2203L−DI−EB4−CTD−2 (Base Part Number 26−00132)
Rated Power 24.7 hp (18.5 KW) @1800 rpm
Displacement 135 in
3
(2.2 liters)
No. Cylinders 4
NOTE: Refer to Table 2–1 for engine speed settings
Weight 439 lbs (199 kg)
Coolant Capacity 2.9 U.S. gallons (11 liters) - 50/50 mix - never to exceed 60/40.
NOTICE
Use Texaco Havoline extended life coolant or any other extended
life coolant which is Dexcool approved and has 5/150 (5 years /
150,000 miles) on the label.
Thermostat Starts to open 177 to 182°F (81 to 83°C). Fully open at 203°F (95°C).
Fuel System
Fuel Winter: Diesel No. 1 Summer: Diesel No. 2 (Maximum 5% Bio-Diesel is also al-
lowed)
Fuel Heater Temperature
Switch
Close on a temperature fall @ 45°F (7.2°C)
Open on a temperature rise @ 75°F (24°C)
Firing Order 1-3-4-2
Engine Preheater (EPH) 42 amps at 12 VDC, resistance approximately 0.3 Ohms
Lubrication System
Engine Oil Pressure 40 to 62 psig (2.8 To 4.2 Bar) - Engine in high speed
Engine Oil Pressure Safety
Switch (ENOPS)
Closes, on pressure rise, at 18 psig (1.22 Bar)
Opens, on pressure fall, at 12 psig (0.82 Bar)
Oil Capacity with Filter 15 quarts (14.2 liters)
Engine Oil Viscosity: API CG or
better OR Mobil Delvac 1
If Outdoor Temp below 32°F (0°C), use 10W30 or Mobil Delvac 1 (5W 40)
If Outdoor Temp above 32°F (0°C), use 10W30 or Mobil Delvac 1 (5W 40) or 15W 40.
Engine Oil Change Intervals Refer to Section 8.2 for information on service intervals.
Battery 12 volt nominal - 90 amp hour capacity Cold cranking amps = 425 DIN, 500 IEC,
725 BCI
Unit Specification
Compressor Model 05G
Type Semi-hermetic Reciprocating
Number of Cylinders 6
Number of Unloaders 2
Weight 137 lbs (62 kg)
Compressor Oil Capacity 5.5 pints (2.8 liters)
Approved Compressor Oil Mobil Arctic EAL 68
To Next Page
Loading...
