Cleaning (Disassembled Generators) ....... 135
Generator Bearing Temperature - Measure/
Record ......................................................... 135
Generator Installation...................................... 34
Location ....................................................... 34
Protective Devices....................................... 34
Receiving Inspection ................................... 34
Storage ........................................................ 34
Unpacking.................................................... 34
Generator Isolating for Maintenance............... 16
Generator Lead (Flat Braided Cable) -
Check (If Equipped)..................................... 135
Generator Lead (Round Cable) - Check (If
Equipped) .................................................... 136
Generator Lead Connections.......................... 24
Grounding the Frame .................................. 26
Lead Numbering .......................................... 24
Multiple Units ............................................... 27
Neutral Connections .................................... 26
Parallel to Utility ........................................... 27
Single Units.................................................. 27
Generator Load - Check................................ 136
Generator Operation ....................................... 93
Block Loading .............................................. 93
Excitation Systems ...................................... 94
Generator Options ....................................... 95
Loading of the Generator............................. 93
Low Idle Adjustment .................................... 94
Oilfield Generators....................................... 95
Power Factor ............................................... 94
Standby Generator Sets .............................. 94
Generator Set - Test ...................................... 137
Generator Set Intended for Stationary Use
Only ............................................................... 24
Generator Set Vibration - Inspect.................. 138
Generator Start-up Checklist......................... 101
H
Hoses and Clamps - Inspect/Replace........... 138
Inspect the Hoses and the Clamps............ 138
Replace the Hoses and the Clamps .......... 139
I
Important Safety Information............................. 2
Installation ....................................................... 34
Instrument Panel - Inspect ............................ 141
Insulation - Test ............................................. 141
Recommended Periodic Insulation Test
Procedure ................................................ 141
Recommended Periodic Insulation Tests .. 141
J
Jacket Water Heater - Check ........................ 144
L
Lifting and Storage .......................................... 32
M
Magnetic Pickups - Clean/Inspect................. 144
Maintenance Interval Schedule..................... 104
Daily ........................................................... 104
Every 100 Service Hours or 3 Months....... 104
Every 12 000 Service Hours or 6 Years..... 105
Every 19 000 L (5000 US gal) of Fuel or 250
Service Hours .......................................... 105
Every 19 000 L (5000 US gal) of Fuel or 500
Service Hours .......................................... 105
Every 2000 Service Hours......................... 104
Every 2000 Service Hours or 1 Year ......... 104
Every 2000 Service Hours or 6 Months..... 104
Every 250 Service Hours........................... 104
Every 379 000 L (100 000 US gal) of Fuel or
5000 Service Hours ................................. 105
Every 6000 Service Hours or 3 Years ....... 105
Every 9500 L (2500 US gal) of Fuel or 250
Service Hours or Yearly ........................... 105
Every Week ............................................... 104
Every Year ................................................. 104
First 19 000 L (5000 US gal) of Fuel or 250
Service Hours .......................................... 105
Overhaul .................................................... 105
PM Level 2 - Every76 000 L (20 000 US gal)
of Fuel or 1000 Service Hours ................. 105
PM Level 3 - Every 228 000 L
(60 000 US gal) of Fuel or 3000 Service
Hours ....................................................... 105
When Required.......................................... 104
Maintenance Recommendations .................... 99
Maintenance Records ................................... 156
Maintenance Section....................................... 96
Model View Illustrations .................................. 18
Model Views .................................................... 18
Mounting and Dismounting ............................. 14
Doors for Generator Enclosures.................. 14
O
Operation Section............................................ 32
Ordering Replacement Parts......................... 155
Overhaul Considerations............................... 144
SEBU7125-13
159
Index Section
To Next Page
Loading...