CAT 3412C - Page 160

Oil Consumption as an Overhaul
Indicator ................................................... 145
Overhaul Recommendation....................... 145
Overspeed....................................................... 73
P
Plate Locations and Film Locations ................ 21
Engine Identification .................................... 21
European Union........................................... 21
Information Plate ......................................... 21
Serial Number Plate..................................... 21
Power Factor - Check.................................... 147
Product Description......................................... 19
Engine Description ...................................... 19
Engine Specifications .................................. 19
Generator Description ................................. 20
Intended Use ............................................... 19
Product Identification Information ................... 21
Product Information Section............................ 18
Product Lifting ................................................. 32
Engine Lifting with a Fuel Tank.................... 32
Engine Lifting with a Generator ................... 32
Product Storage .............................................. 32
Generator Storage....................................... 33
R
Radiator - Clean ............................................ 147
Reference Information Section ..................... 153
Reference Material........................................ 156
Reference Materials ...................................... 156
Reference Numbers ........................................ 22
Record for Reference .................................. 22
Refill Capacities............................................... 96
Refill Capacities and Recommendations ........ 96
Cooling System............................................ 97
Fuel .............................................................. 98
Lubrication System ...................................... 96
Rotating Rectifier - Check ............................. 148
Rotating Rectifier - Test................................. 148
Rectifier Block Test .................................... 149
Testing A Brushless Exciter Rotating Rectifier
With An Ohmmeter .................................. 148
S
Safety Messages............................................... 5
Automatic Engine Starting ............................. 8
Coolant Pressure and Hot Surface................ 5
Diesel Fuel..................................................... 7
High Voltage .................................................. 6
Hot Surface.................................................... 7
Lifting the Generator Set ............................... 6
Servicing the Engine and Reading the
Manual ......................................................... 5
Safety Section ................................................... 5
Severe Service Application - Check.............. 149
Environmental Factors............................... 150
Improper Maintenance Procedures........... 150
Improper Operating Procedures................ 150
Sound Information........................................... 14
Starting Motor - Inspect ................................. 150
Starting the Engine (EMCP II and EMCP II
+ (If Equipped)).............................................. 85
Automatic Starting ....................................... 85
Manual Starting............................................ 85
Starting with Jump Start Cables...................... 86
System Pressure Release............................... 99
Coolant System ........................................... 99
Engine Oil .................................................. 100
Fuel System................................................. 99
T
Table of Contents .............................................. 3
Turbocharger - Inspect .................................. 150
Cleaning and Inspecting ............................ 151
Removal and Installation ........................... 151
V
Voltage Connections ....................................... 27
Single-Phase Current From a Three-Phase
Generator................................................... 29
Three-Phase Voltage Connections ............. 27
Voltage Regulators .............................. 74, 76, 79
Adjustment Procedure for the Voltage
Regulators.................................................. 78
Cat Digital Voltage Regulator (Cat DVR).... 79
Digital Voltage Regulator ............................. 77
Integrated Voltage Regulator (IVR) ............. 80
VR3F............................................................ 77
VR6 .............................................................. 74
W
Walk-Around Inspection ................................ 151
Inspect the Engine for Leaks and for Loose
Connections............................................. 151
Water Pump - Inspect.................................... 152
Welding on Engines with Electronic
Controls ....................................................... 100
160
SEBU7125-13
Index Section