Char-Broil 463341021 User Manual

WARRANTY PART
REPLACEMENT GUIDE -
LED WIRE HARNESS
MODEL
463341021
463341221
463341421
463468021
463468221
463468421
XXXXXXXX • 03/11/21
NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the method
of assembly remains the same.
CAUTION
Read and follow all safety statements, assembly
instructions, and use and care directions before
attempting to assemble and cook.
Some parts may contain sharp edges. Wear protective
gloves if necessary.

Char-Broil 463341021 Specifications

General

Brand	Char-Broil
Model	463341021
Category	Smokers
Type	Electric Smoker
Fuel Type	Electric
Number of Burners	1
Total BTUs	1500
BTU Main Burner	1500
Power Source	Electric
Voltage	120V
Wattage	1500W
Construction Material	Steel

Summary

Warranty Part Replacement Guide - LED Wire Harness

Door Assembly Replacement

Procedure for removing and replacing the grill door assembly.

LED Wire Connection and Disconnection

Steps to disconnect and connect LED wires from the battery box and switch.

Warming Rack and Chef's Delite Grid/Tray Replacement

Instructions for removing and replacing the warming rack and Chef's Delite grid/tray.

Cooking Grates Replacement

Procedure for removing and replacing the main cooking grates.

Heat Tent Replacement

Steps to remove and replace the heat tent.

Burner Components Replacement

Replacing burner hitch pins, carryover tubes, and burner braces.

Sideburner Grate Replacement

Procedure for removing and replacing the sideburner grate.

Side Burner and Associated Parts Replacement

Replacing the side burner, its wiring, venturi clip, and wing screw.

Side Burner Controls Replacement

Steps to remove and replace the side burner knob, bezel, and valve.

Electronic Ignition Module Replacement

Procedure for removing and replacing the electronic ignition module.

Firebox Shelf and Fasteners Replacement

Replacing screws and washers inside the firebox and shelf mounting screws.

Control Panel Replacement

Procedure for removing and replacing the control panel.

Main LED Wire Harness Replacement

Final step to remove and replace the main LED wire harness.