CleanSpace EX - Specifications

CleanSpace Respirators USER INSTRUCTIONS
35
English
Pre-Filters and Coveralls
Product Code
Description
PAF-0036
Particulate Pre-Filter (Standard)
PAF-0057
Particulate Pre-Filter (Large Case Filters)
PAF-0058
Particulate Pre-Filter and Coverall (Standard)
17. Specifications
Air Flow
Manufacturers minimum design flow: 120 litre/minute
Breath-responsive, with max inflow to mask 120 – 200 litre per minute, dependant on altitude,
filter, and battery condition.
Operating
Temperature Range
-10°C to 45°C. (Note: Explosive Atmospheres approvals apply up to maximum ambient
temperature of 40°C) The motor will shut down if the temperature of the battery pack rises
above 60°C or falls below -10°C
Operating Humidity
Range
Zero to 90%, non-condensing
Operating Altitude
Range
Approximately sea level to 1200m
Charging
Temperature Range
0°C to 35°C
Below 0°C and above 35°C the battery may not accept charge
Storage Conditions
Short term storage under 30 days:
Out of direct sunlight, in a clean, dry environment (30% - 50% RH), -10°C to 35°C.
To maintain the integrity of the internal battery, the respirator must be stored under the
following conditions when it will not be used for longer than one (1) month
Long term storage (> 30 days):
Out of direct sunlight, in a clean, dry environment (30% - 50% RH), 18°C to 28°C.
Shelf Life (when
stored as specified)
Charging the battery every 6 months is recommended if the CleanSpace Respirator is not in use.
Particulate Filters: 3 years
Gas and Combined Filters: 3 years
Battery Type
Lithium Ion Polymer
Run Time
Up to 8 hours. Certified to a minimum 4 hours.
Run time is strongly influenced by work rate, filter condition, atmospheric pressure, and other
factors. The run time specified above assumes moderate work rates at sea level with a clean
filter. Different conditions will produce widely varying run times.
Recharge Time
2 hours (to 95%)
Low Battery Voltage
Alarm
Triggers when the remaining run time is around 5 to 10 minutes.
Audible alarm, 3 beeps, repeated every second, 75dB(A) at ear.
Filter Warning
Alarm
Triggers when the filter requires replacement.
Audible alarm sounds until a key is pressed, two (2) beeps repeated every second, 75dB(A) at
ear, and red filter LED flashes. When the alarm first sounds, and if the battery is almost
completely run flat, the maximum flow that can be delivered has been reduced to about 140
litre/minute.
Charger
Input: 100 – 240VAC, 50 – 60 Hz. Output: 14.7 VDC, 24 Watts
Intrinsic Safety
CleanSpace EX is certified to IECEx and ATEX and ETL standards. See Approvals above.