CSC City Slicker - Frame and Body Maintenance

To Next Page

To Previous Page

CitySlickerOwner’sandServiceManual

www.CSCMotorcycles.com



22



Placethemotorcycleonitssidestand.Unscrewthebattery

compartmentretentionknob.



Removethebatterycompartmentdoorretentionknob.

Notethatitistetheredtothemotorcycle.



Swingthebatterycompartmentdooroutward.



RemovethetwosmallPhillipsheadscrewssecuringtheright

(forward)halfofthemainpowerconnector.



Disconnecttheright(forward)halfofthemainpower

connector.



Main Page

Table of Contents2
A Word from Steve4
Foreword5
Caution and Warning Symbols5
Section 1: Owner's Manual6
General Motorcycle Safety Guidance6
City Slicker Specifications7
Inspections before Riding8
City Slicker Components9
VIN and Motor Number10
City Slicker Controls and Operation10
City Slicker Reverse Operation12
Load Limits12
Instrument Cluster Indicators and Switches12
Storage Compartment14
Tool Kit14
Battery Charging14
Cleaning Your Motorcycle17
Storing Your Motorcycle18
Section 2: Service Manual19
Maintenance Cautions and Warnings19
Component Cleaning19
Parts Inspection19
Recommended Maintenance Intervals20
Torque Values20
Unpacking21
Inspection21
Frame and Body21
Battery Removal22
Body Panel Removal25
Positioning the Motorcycle on a Jack27
Front and Rear Wheel Removal27
Front Wheel Removal27
Rear Wheel Removal29
Brakes31
Front Brake Pad Inspection and Replacement31
Front Rotor Inspection and Replacement34
Rear Brake Pad Inspection and Replacement34
Rear Rotor Inspection and Replacement36
Flushing and Replacing the Brake Fluid36
Bleeding the Brakes37
Brake Troubleshooting37
Front and Rear Wheel Bearing Removal38
Suspension38
Front Fork Seal Replacement39
Rear Shock Absorber Replacement42
Rear Shock Absorber Adjustment42
Wheel and Tire Inspection and Maintenance43
Wheel and Tire Troubleshooting43
Replacing Tires43
Drive System45
Rear Wheel Alignment and Drive Belt Adjustment45
Cush Drive Replacement46
Motor Removal and Replacement47
Belt Replacement49
Electrical System50
Electrical Components Location50
Headlight Replacement52
Instrument Cluster Removal and Replacement54
Ignition Switch Removal and Replacement54
Front and Rear Turn Signal/Brake Light Replacement55
License Plate Light Replacement58
Controller Removal and Replacement59
Built in Test Equipment and Electrical System Troubleshooting60
Electrical Schematic62

CSC City Slicker - Frame and Body Maintenance

Table of Contents

Related product manuals