As the exhaust gas high pressure and
heat energy spins the turbine fins
which is installed at the exhaust has
exit at a high speed, the compressor
fins which is directly connected to the
turbine axe spins at the same speed to
provide excess fresh air into the engine
cylinder.
Vehicle operating mrthod
Since the turbo charger spins at a high
speed, when engine oil is supplied too
late or too insufficiently, it might bring
harm to the bearing.
It is therefore essential that you follow
the instructions for starting the vehicle
and maintenance matters before and
after operating the vehicle.
●
Before operating the vehicle
Do not start driving right after ignition.
You may start driving once you allow
the engine to run for 3 minutes so that
enough oil is supplied to each
lubrication conpartment of the turbo
charger.
●
After operating the vehicle
Do not turn the car off right after wide-
open throttle operation.
When suddenly suspending the engine
at a wide open throttle condition, the
high temperature from the exhaust gas
and oil might cause the turbo charger’s
lubrication compartment to leak.
You should therefore turn the car off
after 5 minutes of running(idling)
Maintenance method
Since the turbo charger spins at a very
fast speed (50,000~200,000rpm), it is
very sensitive to the dust particles and
other substances from the air, and
pollution and insufficient supply of
engine oil. It is therefore very important
that you pay close attention to its
maintenance.
●
Maintaining the air cleaner
To prevent the turbo charger’s compressor’s
fin and driving section from early
deterioration and breakdown due to
inhalation of dust particles and other
substances, you must regularly clean
and replace the air cleaner element and
also inspect it there is any defect in the
connection hose between the air
cleaner and the turbo charger.
●
Maintaining the engine oil
Always use standard oil and standard
oil filter and adhere to replacement
period intervals.
2
-
7
5. DIRECTIONS FOR TURBO CHARGER INSTALLED VEHICLES
SAFETY CAUTIONS
Turbocharger
OM-B399E
To Next Page
Loading...