Dolmar PS-5105 - Trouble Shooting; EU Conformity Declaration

29
EU Conformity Declaration
The undersigned, Rainer Bergfeld, as authorized by DOLMAR GmbH, declare that the DOLMAR machines,
Type: 180, 181, 183  EUprototypetestcerticateNo.
PS-4605, PS-4605 H (180) 4811004.11009
PS-5105, PS-5105 H (181) 4811004.11009
PS-5105 C, PS-5105 CH (183) 4811004.11009
manufactured by DOLMAR GmbH, Jenfelder Str. 38, 22045 Hamburg, Germany, conforms to the basic safety and health require-
ments of the applicable EU Directives:
EU Machinery Directive 2006/42/EG, EU EMC Directive 2004/108/ EG, Outdoor Noise Directive 2000/14/EG.
The most important standards applied to properly meet the requirements of the above EU Directive were: EN 11681-1, EN ISO
14982, CISPR 12.
The conformity assessment procedure 2000/14/EG was performed per Annex V. The measured noise level (L
wa
) is 111 dB(A). The
guaranteed noise level (L
d
) is 112 dB(A).
TheEU‑Type‑ExaminationCerticatewasperformedby:DEKRATestingandCerticationGmbH(2140),Enderstraße92b,D‑01277
Dresden. The technical documentation is on file at DOLMAR GmbH, Jenfelder Straße 38,Abteilung FZ, D‑22045
Hamburg.
Hamburg, 1.8.2014
For DOLMAR GmbH
Rainer Bergfeld
Managing Director
Trouble shooting
Malfunction System Observation Cause
Chain does not run Chain brake Engine runs Chain brake actuated.
Engine does not start or Ignition system Ignition spark Malfunction in fuel supply system, com-
onlywithdifculty   pressionsystem,mechanicalmalfunction.
No ignition spark Switch on STOP, fault or short-circuit in the
wiring, plug cap or spark plug defective.
 Fuelsupply Fueltankislled CombinationswitchinChokeposition, 
carburetor defective, suction head dirty, fuel
line bent or interrupted.
Compression Inside Cylinder base packing ring defective, radial
system shaft packings defective, cylinder or piston
rings defective
Outside Spark plug does not seal.
Mechanical Starter does not engage Spring in starter broken, broken parts
malfunction inside the engine.
Warmstartdifculties Carburetor Fueltankislled Wrongcarburetoradjustment.  
Ignition spark
Enginestarts,but Fuelsupply Fueltankislled Wrongidlingadjustment,suctionheador 
dies immediately carburetor dirty.
Tank venting defective, fuel line interrupted,
cable defective, Combination switch defective
Insufcientpower Severalsystems Engineisidling Airlterdirty,wrongcarburetoradjustment, 
 maybeinvolved  muferclogged,exhaustchannelincylinder 
simultaneously clogged, spark arrester screen clogged.
No chain lubrication Oil tank/pump No oil on the chain Oil tank empty.
Oil guide groove dirty.
Oil-pump adjusting screw incorrectly adjusted.