Dometic D21 - Default Chapter; Table of Contents

2
EN
Contents Range
Service Center & Dealer Locations
Visit: www.dometic.com
Read these instructions carefully.
Contents
1 Explanation of Symbols and Safety
Instructions ............................ 3
1.1 Recognize Safety Information .............3
1.2 Understand Signal Words ................3
1.3 Supplemental Directives .................3
1.4 General Safety Messages ................3
2 Intended Use ........................... 4
3 Troubleshooting ........................ 4
4 General Information ..................... 7
4.1 Tools and Materials .....................7
4.2 Model Identification ....................7
4.3 Component Locations. . . . . . . . . . . . . . . . . . . 8
4.4 Wiring ..............................10
4.5 General Range Terminology .............10
5 Diagnostic Procedures ...................11
6 Installation Issues ...................... 18
6.1 Gas Pressure Issue .....................18
6.2 Negative Air Draft Issue .................18
6.3 Structure Issue ........................18
6.4 Power Issue ..........................18
7 Service Procedures ..................... 19
7.1 Accessing the Range Components .......19
7.2 Accessing the Range Components for
RA/RV Models ........................19
7.3 Performing a Leak Test ..................20
7.4 Checking the Gas Pressure ..............20
7.5 Straightening the Flex Line ..............21
7.6 Adjusting the Air/Gas Mixture ...........21
7.7 Testing the 12 VDC Ignition Module .......22
7.8 Cleaning and Clearing the Orifice ........22
7.9 Clearing the Oven Flue (Vent) ............23
7.10 Repositioning the Thermal Bulb ..........24
7.11 Aligning the Thermocouple .............24
7.12 Replacing the Oven Bulb ...............25
7.13 Replacing the Oven Light Switch
and Wires ............................25
8 Maintenance .......................... 26
8.1 Changing the Battery in the Battery Ignition
Module .............................26
8.2 Testing the Control knobs ...............26
8.3 Cleaning ............................27
9 Disposal .............................. 27
10 Replacement Parts ..................... 27