EV-97 Eurostar SL Microlight Maintenance Manual GEN/EUR/04 Issue 4 23
Check attachment of brake system plastic hoses
to the main leg
Visually check brake pads for condition and
uneven wear- replace pads if needed
Check wear and security of brake discs
Check brake system for leaks
- add brake fluid and bleed the system if a brake
Check brake fluid level – top up to 25mm above
the bottom of the reservoir as necessary.
Visually check for loose rivets, deformation,
cracks and damage – contact the aircraft
manufacturer if in doubt.
Check play of wing attachments – move the wing
tip upward-downward, forward-rearward. Contact
the aircraft manufacturer if play exceeds
tolerances (see sect. 17)
Check condition and attachment of fiberglass
wing tips
Check Vortex Generators (VG’s) for dirt build up,
damage and adhesion. (29 per wing)
Check play (see Section 17)
Check security of control rod ends
Lubricate per Lubricating Chart
Remove inspection covers from the lower wing
surface to check security and to lubricate control
system joints. Refit covers.
Lubricate per Lubricating Chart.
Fully extend the flaps and visually check condition
Check play (see Section 17)
Check condition of flap control pin and wear of the
groove at the flap root
Lubricate per Lubricating Chart
Check pitotstatic head attachment to wing.
Check pitotstatic system for leaks
Remove wing root fairings.
Visually check condition and security of wing
attachments
Lubricate per Lubricating Chart
To Next Page
Loading...
