Weekly Post-trip Inspection Checklist
See the following table for procedures that should be
performed weekly, post-trip. Place a check mark in
the complete (Comp.) column to indicate a proce-
dure has been performed.
Inspector Date
Engine Compartment Comp.
1 Windshield washer reservoir level
2 Air intake restriction indicator
3 Automatic transmission fluid level
4 Water in fuel/water separator
5 Steering components
6 Serpentine drive belts
Monthly Post-trip Inspection Checklists
See the following tables for procedures that should
be performed monthly, post-trip. Place a check mark
in the complete (Comp.) column to indicate a proce-
dure has been performed.
Inspector Date
Brake Components Comp.
1 Brake system components
2 Brake chambers
3 Air brake lines
4 Flex air lines
5 Brake linings and brake drums
6 Brake lining thickness
Saddle Tank Areas Comp.
1
Drain air reservoirs (with automatic drain
valves)
2 Batteries (location may vary)
Engine Compartment Comp.
1 Hydraulic clutch reservoir
2 Radiator and heater hoses
3 Steering wheel play
Fluids Added
Use the following table to note any fluids that were
added during the inspection and maintenance proce-
dures.
Fluids Added During Inspection
Fluid Amount Added
Wheel Bearing Lubricant
Engine Oil
Power Steering Fluid
Engine Coolant
Windshield Washer Fluid
Automatic Transmission
Fluid
Hydraulic Clutch Fluid (DOT
4 brake fluid)
Pretrip and Post-Trip Inspections and Maintenance
11.2
To Next Page
Loading...
