Home
Froling
Boiler
T4 Series
Froling T4 Series User Manual
5
of 1
of 1 rating
43 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
2.10.3 Fire in the system
DANGER
In case of fire in the system:
Risk of death by fire and poisonous gases
Emergency procedure in case of fire:
❒
Leave the boiler room
❒
Close the doors
❒
Inform the fire department
2
Safety
Emergency procedure
20
Froling GesmbH | A-4710 Grieskirchen, Industriestraße 12 | www.froeling.com
19
21
Table of Contents
Operating Instructions
1
Table of Contents
2
General T4 Product Overview
5
T4 Product Overview
5
Hazard Levels of Warnings
7
Pictograms Used
7
Safety
7
General Safety Information
8
Permitted Uses
10
The Clean Air Act 1993 and Smoke Control Areas
10
Permitted Fuels
11
Wood Chips
11
Wood Pellets
11
Changing the Fuel
11
Non-Permitted Fuels
12
Protective Equipment for Operating Staff
12
Qualification of Operating Staff
12
Design Information
13
General Information for Installation Room (Boiler Room)
13
Installation and Approval of the Heating System
13
Requirements for Central Heating Water
14
Notes for Using Pressure Maintenance Systems
15
Chimney Connection/Chimney System
16
Return Temperature Control
16
Use with Storage Tank
16
Safety Devices
17
Residual Risks
18
Emergency Procedure
19
Overheating of the System
19
Smell of Flue Gas
19
Fire in the System
20
Operating the System
21
Operating the System Assembly and Initial Startup
21
Filling/Refilling the Store with Fuel
22
Loading of Fuel for a Partially Emptied Store with Rotary Agitator
22
Loading Wood Chips in an Empty Store (Not under Pressure)
22
Blowing in Fuel for a Partially Emptied Store with Rotary Agitator
23
Blowing in Fuel for an Empty Store with Rotary Agitator
23
Blowing in Pellets for a Store with Pellet Screw
23
Heating up the Boiler
24
Regulating the Boiler
25
Switching off the Boiler
25
Switching off the Power Supply
25
Switching on the Boiler
25
Switching on the Power Supply
25
Boiler Servicing
26
General Information on Servicing
26
Inspection
28
Checking the System Pressure
28
Checking the Safety Valve
28
Checking the Geared Motors
28
Inspection and Cleaning
28
Cleaning
29
Emptying the Ash Container
29
Recurrent Check and Cleaning
31
Before Starting Inspection and Cleaning Work
31
After Inspection and Cleaning Work
31
Clean the Combustion Chamber
32
Cleaning the Heat-Exchanger and Flue Gas Collection Chamber
33
Clean the Heat Exchanger Pipes
35
Cleaning the Flue Gas Temperature Sensor
36
Cleaning the Flue Gas Pipe
36
Check the Seal on the Doors
37
Checking the Draught Controller Flap
38
Cleaning the Measurement Line of the Underpressure Controller
38
Emissions Measurement by Chimney Sweep or Regulatory Body
39
Maintenance Agreement / Customer Service
39
Preparing for the Measurement
39
Disposal Information
40
Disposal of System Components
40
Disposal of the Ash
40
Replacement Parts
40
Behaviour of System after a Power Failure
41
Excessive Temperature
41
General Fault with Power Supply
41
Troubleshooting
41
Acknowledging a Fault Message
42
Appendix
43
Appendix Addresses
43
Faults with Fault Message
42
Procedure for Fault Messages
42
Address of Manufacturer
43
Customer Service
43
Address of the Installer
43
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Froling T4 Series and is the answer not in the manual?
Ask a question
Froling T4 Series Specifications
General
Brand
Froling
Model
T4 Series
Category
Boiler
Language
English
Related product manuals
Froling T4e
76 pages
Froling TX 200
55 pages
Froling TX 250
40 pages
Froling S3 Turbo
45 pages
Froling S4 Turbo
40 pages
Froling FHG Turbo
11 pages
Froling FHG Turbo 3000
25 pages
Froling Turbomat TM 320
87 pages
Froling Turbomatic TMC 70
39 pages
Froling P4 Pellet 8 - 60
31 pages
Froling P4
51 pages
Froling P2-25
80 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General