Fuji Electric Micro-Controller X Socket type Instruction Manual

 &DXWLRQ
&DXWLRQVZKHQ,QVWDOOLQJ
3OHDVHDYRLGLQVWDOOLQJLQWKHIROORZLQJORFDWLRQV
Ɣ/RFDWLRQVLQZKLFKWKHDPELHQWWHPSHUDWXUHIDOOVRXWVLGHWKHUDQJHRI±WR&ZKHQHTXLSPHQW
LVLQXVH,IWKH SRZHU VXSSO\LV9$&WKHUHFRPPHQGHGPD[LPXPDPELHQWWHPSHUDWXUHLV
45°C.)
Ɣ/RFDWLRQVZLWKUDSLGWHPSHUDWXUHFKDQJHVOHDGLQJWRGHZFRQGHQVDWLRQ
Ɣ/RFDWLRQVZLWKFRUURVLYHJDVHVHVSHFLDOO\VXO¿GHJDVDPPRQLDHWFRUÀDPPDEOHJDVHV
Ɣ/RFDWLRQVZLWKYLEUDWLRQRUVKRFNGLUHFWO\9LEUDWLRQDQGVKRFNPD\FDXVHRXWSXWUHOD\PDOIXQFWLRQ
Ɣ/RFDWLRQVLQFRQWDFWZLWKZDWHURLOFKHPLFDOVVWHDPRUKRWZDWHU
 ,IWKHHTXLSPHQWJHWVZHWWKHUH LV DULVNRIHOHFWULF VKRFN RUILUHVRKDYH LW LQVSHFWHGE\)XML
distributor.)
Ɣ/RFDWLRQVZLWKKLJKFRQFHQWUDWLRQVRIDWPRVSKHULFGXVWVDOWRULURQSDUWLFOHV
Ɣ/RFDWLRQVZLWKODUJHLQGXFWLYHLQWHUIHUHQFHUHVXOWLQJLQVWDWLFHOHFWULFLW\PDJQHWLF¿HOGVRUQRLVH
Ɣ/RFDWLRQVLQGLUHFWVXQOLJKW
Ɣ/RFDWLRQVWKDWEXLOGXSKHDWIURPUDGLDQWKHDWVRXUFHVHWF
Recommended site conditions
Ɣ$SODFHZKHUHWKHDPELHQWKXPLGLW\GXULQJRSHUDLRQLVEHWZHHQWR5+
About EMC standard
Ɣ7KLVHTXLSPHQWLVDFODVV$IRULQGXVWULDOORFDWLRQVHTXLSPHQW'RQRWXVHWKLVHTXLSPHQWLQGRPHVWLF
establishment, such as residential areas, or it may cause radio interference. If you use this equipment in
domestic locations, take adequate measures on the outside of the equipment to reduce radio interference.
Ɣ8QGHUWKHUHTXLUHPHQWRI(0&VWDQGDUGWKHPD[LPXPOHQJWKRIH[WHUQDOFDEOHLQFOXGLQJDVHQVRUWREH
connected to this equipment is 30 m. Do not connect the sensor longer than 30 m.
&DXWLRQVZKHQ$WWDFKLQJWRWKH3DQHOV
Ɣ,QVHUWWKHFRQWUROOHUXQLWLQWRWKHSDQHOFXWRXWIURP WKHIURQWDQGWKHQSXW WKHPRXQWLQJEUDFNHW
IURPWKHUHDU7KHPRXQWLQJEUDFNHWVKRXOGEHSXVKHGLQXQWLOWKHFRQWUROOHULVVHFXUHO\¿[HGWRWKH
SDQHO,IWKHUHLVDVOLJKWJDSUHPDLQLQJJHQWO\WLJKWHQWKHWZRVFUHZVXQWLOWKHJDSGLVDSSHDUV
 0DNHVXUHQRW WRRYHUWLJKWHQWKHVFUHZV DVGRLQJVRPD\UHVXOW LQWKHPRXQWLQJEUDFNHW
separating from the stopper.)
Ɣ7KHIURQWRIWKLVHTXLSPHQWLVZDWHUSURRILQFRPSOLDQFHZLWK1(0$;VWDQGDUGV,3HTXLYDOHQW
 7RHIIHFWZDWHUSURRIWKHLQFOXGHGSDFNLQJLVVKDOOEHDWWDFKHG EHWZHHQ WKHFRQWUROOHUDQGWKH
SDQHODFFRUGLQJWRWKHJXLGHOLQHVEHORZ,QFRUUHFWDWWDFKPHQWPD\FDXVHWKHHTXLSPHQWWRORVHLWV
ZDWHUSURRIFDSDELOLWLHV
 $VVKRZQLQ)LJLQVHUWWRWKHSDQHODIWHUDWWDFKLQJWKHSDFNLQJWRWKHHTXLSPHQWFDVH
 $VVKRZQLQ)LJWLJKWHQWKH¿[WXUHVFUHZVVRWKDWQRJDSVFDQUHPDLQEHWZHHQWKHHTXLSPHQW
IDFHWKHSDFNLQJDQG WKH SDQHOV2QFH¿QLVKHGFRQ¿UP WKDW WKHUHDUHQRFKDQJHV LQ VKDSH
VXFKDVGLVSODFHGRULPSURSHUO\¿WWHGSDFNLQJHWFDVVKRZQLQ)LJ
Ɣ,IWKHSDQHOGRHVQRWKDYHHQRXJKVWUHQJWKJDSVPD\GHYHORSEHWZHHQWKHSDFNLQJDQGWKHSDQHO
WRORVHZDWHUSURR¿QJFDSDELOLWLHV
Fig. 1 Fig. 2 Fig. 3
Screw
Mounting
bracket
Unit Unit
Front Case Panel Panel
Packing
Packing
Case
Case
(Bad)
(Good)
Packing
Attachment on vertical surface
+RUL]RQWDODWWDFKPHQW
Caution
Ɣ ,QRUGHUWRDLGKHDWGLVVLSDWLRQGRQRWEORFNWKHVLGHVRIWKHHTXLSPHQW
Ɣ 'RQRWEORFNWKHDLUYHQWVRQWKHWRSDQGERWWRPRIWKHFDVH
&DXWLRQVIRU:LULQJ
Ɣ)RUWKHUPRFRXSOHLQSXWXVHWKHGHVLJQDWHGFRPSHQVDWLRQOHDGIRUUHVLVWDQFHEXOELQSXWXVHZLUHV
ZLWKVPDOOOHDGZLUHUHVLVWDQFHDQGZLWKRXWDQ\UHVLVWDQFHGLIIHUHQFHDPRQJWKHWKUHHZLUHV
Ɣ7RDYRLGQRLVHFRQGXFWRUHIIHFWVLQSXWVLJQDOZLUHVVKRXOGEHVHSDUDWHGIURPHOHFWULFSRZHUOLQHVRU
load lines.
Ɣ,QSXWVLJQDOZLUHDQGRXWSXWVLJQDOZLUHVKRXOGEHVHSDUDWHGHDFKRWKHU$QGERWKVKRXOGEHVKLHOG
ZLUH
Ɣ,IWKHUHLVDORWRIQRLVHIURPWKHSRZHUVRXUFHDGGLQJDQLQVXODWLRQWUDQVGXFHUDQGXVLQJDQRLVH
¿OWHULVUHFRPPHQGHG
 $OZD\VDWWDFKDQRLVH¿OWHUWRDSDQHOWKDWLVJURXQGHGVHFXUHO\DQGNHHSWKHZLULQJEHWZHHQWKH
QRLVH¿OWHURXWSXWVLGHDQGWKHPHDVXULQJHTXLSPHQWSRZHUWHUPLQDOZLULQJWRDPLQLPXPOHQJWK
 3OHDVHGRQRWDWWDFKIXVHVDQGVZLWFKHVHWFWRWKHQRLVH¿OWHURXWSXWZLULQJRWKHUZLVHWKH¿OWHU¶V
HIIHFWLYHQHVVZLOOEHGHFUHDVHG
Ɣ7ZLVWLQJWKHSRZHUZLUHVLVHIIHFWLYHZKHQFRQQHFWLQJWKHZLUHV7KHVKRUWHUWKHSLWFKRIWKHWZLVW
the more effective the connection is against noise.)
Ɣ2SHUDWLRQSUHSDUDWLRQWLPHLVUHTXLUHGIRUWKHFRQWDFWRXWSXWZKHQSRZHULVWXUQHGRQ,IXVLQJLWDV
DVLJQDOWRDQH[WHUQDOLQWHUORFNFLUFXLWSOHDVHFRXSOHLWZLWKDGHOD\HGUHOD\
Ɣ&RQFHUQLQJWKHRXWSXWUHOD\FRQQHFWLQJWKHPD[LPXPUDWHGORDGZLOOVKRUWHQWKHSURGXFW¶VOLIHVR
SOHDVHDWWDFKDQDX[LOLDU\ UHOD\,IWKHRXWSXWRSHUDWLRQIUHTXHQF\LVKLJKVHOHFWLQJ D665GULYH
output type is recommended.
[Proportionate cycles] Relay output: 30 seconds or more, SSR drive output: 1 second or more
Ɣ,I\RXVHOHFWHGWKHYHUVLRQZLWK&7XVHDFRPPRQSRZHUOLQHIRUWKHKHDWHUDQGWKHFRQWUROOHU
Ɣ:KHQLQGXFWLYHORDGVVXFKDVPDJQHWLFRSHQLQJFORVLQJHTXLSPHQWHWFDVUHOD\RXWSXWHTXLSPHQW
are connected, use of a surge absorber is recommended in order to protect the contacts against
opening/closing surges and to ensure long-term use.
 5HFRPPHQGHGVSHFL¿FDWLRQIRUWKHVXUJHDEVRUEHU
Voltage Nominal varistor voltage
100 V 240 V
200 V 470 V
 $WWDFKPHQWSRVLWLRQEHWZHHQWKHUHOD\FRQWURORXWSXWFRQWDFWV
13
16
17
18
14
15
7
8
10
11
12
9
1
2
4
5
6
3
(Example)
.H\2SHUDWLRQ&DXWLRQV(UURU2SHUDWLRQV
Ɣ7KHDODUPIXQFWLRQGRHVQRWZRUNSURSHUO\ZKHQDQHUURUWDNHVSODFHXQOHVVWKHVHWWLQJVDUHPDGH
FRUUHFWO\$OZD\VYHULI\LWVVHWWLQJEHIRUHRSHUDWLRQ
Ɣ,I WKH LQSXWZLULQJEUHDNVWKHGLVSOD\ ZLOO UHDG8888RU//// :KHQ UHSODFLQJWKHVHQVRU
DOZD\VWXUQWKHSRZHU2))
2WKHUV
Ɣ3OHDVHGRQRWZLSHWKHHTXLSPHQWZLWKRUJDQLFVROYHQWVVXFKDVDOFRKRORUEHQ]HQHHWF,IZLSLQJ
is necessary, use a neutral cleaning agent.
Ɣ'RQRWXVHPRELOHSKRQHVQHDUWKLVHTXLSPHQWZLWKLQFP2WKHUZLVHDPDOIXQFWLRQPD\UHVXOW
Ɣ7URXEOHPD\RFFXULIWKHHTXLSPHQWLVXVHGQHDUDUDGLR79RUZLUHOHVVGHYLFH
Ɣ7KLVHTXLSPHQWVKRXOGEHWUHDWHGDVDQLQGXVWULDOZDVWHZKHQLWLVGLVSRVHGRI
)RU3URSHU8VDJH
Please con¿rm that the model delivered matches your order.
0RGHO6SHFL¿FDWLRQVSDJH
Terminal connections diaJram
"4 WirLQJSDJH
&KDQJLQJVHWvalue
Basic Operation Methods
Parameter List
Input/Output/Control
"5 Display and OperDWLRQVSDJH
"5 Display and OperDWLRQVSDJH
ParDPHWHU/LVWSDJHWR
)XQFWLRQVSDJH
6HWWLQJRILQSXWVHQVRUDQGLQSXWrDQJH
6HOHFWLQJFRQWUROPHWKRG
&RQWUROOLQJWKURXJKDXWRWXQLQJ
WRPDWLFVHWWLQJSDrameters
,QSXW6HWWLQJSDJH
&RQWURO6HWWLQJSDJH
AXWRWXQLQJSDJH
)X]]\3,'&RQWURO6HOIWXQLQJ&RQWUROSDJH
Display durLQJHTXLSPHQWHUURU
(UURU,QGLFDWLRQVSDJH
([WHrnal dimensions
Panel cut dimensions
0RXQWLQJWKHSDQHO
,QVWDOODWLRQDQG0RXQWLQJSDJH
&RQ¿rmation of model code
2
Wiring Connection
3 Display and Operations
4 Parameter List
5 Functions of the Temperature Controller
Turn Power On
6 Advanced Usage
7 Error Indications
Operation
1 Installation and Mounting
Caution
:DLWPLQXWHVIRUWKHFRQWUROOHUWRVWDELOL]HGWKHUPDOO\2SHUDWLRQVVXFKDV
measurements should be taken after the equipment has been on for 30 minutes
or more.
- 2 -

Fuji Electric Micro-Controller X Socket type Specifications

General

Brand	Fuji Electric
Model	Micro-Controller X Socket type
Category	Temperature Controller
Language	English