EasyManua.ls Logo

HANKISON HPRP 1000 - User Manual

Default Icon
20 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
REFRIGERATED
TYPE
COMPRESSED
AIR DRYERS
CONTENTS
GENERAL SAFETY INFORMATION .........................2
RECEIVING, MOVING, AND UNPACKING ................2
1.0 INSTALLATION ..................................................3
2.0 OPERATION.......................................................5
3.0 MAINTENANCE .................................................8
SIZING ......................................................................9
ELECTRICAL SCHEMATICS ....................................10
DIMENSIONS AND WEIGHT ....................................14
ENGINEERING DATA ...............................................15
TROUBLESHOOTING GUIDE ..................................16
PARTS LIST: AIR-COOLED UNITS ..........................17
PARTS LIST: WATER-COOLED UNITS ...................18
WARRANTY..............................................................20
SERVICE DEPARTMENT: (724) 746-1100
INSTRUCTION MANUAL
Models: HPRP 1000, 1250, 1500, 1750,
2000, 2500, 3000
7610.483.37 Rev. C 6/05
Internal Use Only
483.37c/050626

Table of Contents

Questions and Answers

  • S
    Susan HawkinsAug 12, 2025
    Why is there water downstream of my HANKISON Dehumidifier?
    • C
      Calvin ClarkAug 12, 2025
      If there's water downstream of your HANKISON Dehumidifier, it could be due to several reasons. Residual free moisture might be lingering in the pipelines, in which case you should blow out the system with dry air. The air bypass system might be open, so check the valve positions. Ensure the inlet and outlet connections are correctly connected. Air lines downstream could be exposed to temperatures below the dew point, so insulate or heat trace them, or use dry air to lower the dew point. Also, excessive free moisture could be at the dryer inlet, so install a separator ahead of the dryer. Finally, the condensate may not be draining, the dryer might be overloaded, or the refrigeration system may not be functioning correctly.
  • N
    Noah DavisAug 16, 2025
    What causes high pressure drop across HANKISON Dehumidifier?
    • M
      Michael WestAug 16, 2025
      A high pressure drop across your HANKISON Dehumidifier can occur if the air flow is excessive; check the flow rate. It could also be due to freezing of moisture in the evaporator because of a refrigeration system fault, or the filter might be loaded with solid particulates, requiring you to replace the filter element.
  • D
    David LucasAug 19, 2025
    What to do if the power on light is off on my HANKISON HPRP 1000 Dehumidifier?
    • D
      David JenkinsAug 19, 2025
      If the power on light is off on your HANKISON Dehumidifier, first check for power to the dryer, as there may be a power failure or open circuit. Also, verify the current command status, as the compressor may be commanded off by a manual switch or programmed schedule.
  • B
    bchambersAug 23, 2025
    What to do if the compressor on light is off on my HANKISON HPRP 1000?
    • W
      williamromeroAug 23, 2025
      If the compressor on light is off on your HANKISON Dehumidifier, check the power to the compressor because there may be an open circuit.
  • R
    Richard ReyesAug 27, 2025
    Why is my HANKISON HPRP 1000 Dehumidifier showing a high temperature?
    • J
      Jennifer NelsonAug 27, 2025
      A high temperature on your HANKISON Dehumidifier, also observed as a high reading on the temperature indicator, may be due to an elapsed service interval, so perform the scheduled service. It may also be caused by the hot gas bypass valve requiring adjustment, so contact a qualified technician or the manufacturer’s service department. Finally, it may be caused by low refrigerant.
  • Y
    ybarrettAug 30, 2025
    How to fix a restricted or frozen drain line on HANKISON HPRP 1000 Dehumidifier?
    • C
      Christopher JohnsonAug 30, 2025
      If the drain line is restricted or frozen on your HANKISON Dehumidifier, open the drain line.
  • R
    Renee MartinezSep 3, 2025
    What to do if the temperature sensor or wiring to sensor is open on HANKISON HPRP 1000 Dehumidifier?
    • N
      nicole69Sep 4, 2025
      If the temperature sensor or wiring to the sensor is open on your HANKISON Dehumidifier, replace the sensor or repair the wiring.
  • L
    lisamorrisSep 7, 2025
    What to do if the temperature sensor or wiring to sensor is shorted on HANKISON Dehumidifier?
    • E
      erika45Sep 7, 2025
      If the temperature sensor or wiring to the sensor is shorted on your HANKISON Dehumidifier, replace the sensor or repair the wiring.

Summary

General Safety Information

Receiving, Moving, and Unpacking

Installation

Location

Details on where to place the dryer for optimal performance and safety.

Operation

Minimum;Maximum Operating Conditions

Specifies the environmental and air parameters for safe dryer operation.

Start-up Procedure

Step-by-step procedure for safely starting the dryer after installation.

Control Panel Overview

Explanation of the buttons, display, and indicators on the dryer's control panel.

Maintenance

Condenser Coil Cleaning

Instructions for cleaning the condenser coil on air-cooled and water-cooled units.

Separator;Filter Replacement

Guidance on when and how to replace the moisture separator and filter elements.

Sizing

Electrical Schematics

Dimensions and Weight

Engineering Data

Troubleshooting Guide

Troubleshooting Common Issues

Lists common symptoms, their potential causes, and corrective actions.

Parts List: Air-Cooled Units

Parts List: Water-Cooled Units

Warranty

HANKISON HPRP 1000 Specifications

General IconGeneral
BrandHANKISON
ModelHPRP 1000
CategoryDehumidifier
LanguageEnglish

Related product manuals