TABLE OF CONTENTS
SAFETY INSTRUCTIONS AND WARNING TAGS 2
SAFETY PRECAUTIONS 3
INTRODUCTION 4
OPERATING DATA 4
INSTALLATION 5
LUBRICATION 6
PREVENTATIVE MAINTENANCE 7
STARTUP CHECKLIST 7
TROUBLESHOOTING 8
RECOMMENDED SHUTDOWN PROCEDURE 9
MAINTENANCE 10
RECOMMENDED LUBRICANTS 11
CUTAWAY VIEW AND PARTS LIST 12
WARRANTY STATEMENT 13 & 14
NOTE SECTION 15
SAFETY PRECAUTIONS
For equipment covered specifically or indirectly in this instruction book, it is important that all personnel observe
safety precautions to minimize the chances of injury. Among many considerations, the following should particularly be
noted:
• Blower casing and associated piping or accessories may become hot enough to cause major skin burns on
contact.
• Internal and external rotating parts of the blower and driving equipment can produce serious physical injuries.
Do not reach into any opening in the blower while it is operating, or while subject to accidental starting. Cover
external moving parts with adequate guards.
• Disconnect power before doing any work, and avoid bypassing or rendering inoperative any safety or
protective devices.
• If blower is operated with piping disconnected, place a strong, coarse screen over the inlet and avoid
standing in discharge air stream.
• Avoid extended exposure in close proximity to machinery with high intensity noise levels.
• Use proper care and good procedures in handling, lifting, installing, operating, and maintaining the
equipment.
• Other potential hazards to safety may also be associated with operation of this equipment. All personnel
working in or passing through the area should be warned by signs and trained to exercise adequate general
safety precautions.
• Hearing protection may be required depending on silencing capabilities.
3
IMPORTANT
In order to assure you of the full benefits of our product warranty, please complete, tear out and
return the warranty registration card located on the back cover of this manual, or you can register
your product online at http://pneumatics.tuthill.com/product_registration
To Next Page
Loading...
