ILMOR MV8 User Manual

SECTION 3 ILMOR MV8 OWNER’S MANUAL
3-2 © 5/2013 Ilmor Marine, LLC, Version 1.0
Be certain to read carefully the boat manufacturer’s Owner’s Manual
section on fueling for additional information and details. is is a critical
component of safe and enjoyable boating.
DANGER! Never start the engine if a gasoline odor is present or if
gasoline can be seen at any point along the fuel line, along the fuel tank,
in the bilge or at the engine.
FUEL REQUIREMENTS
e Ilmor MV8 engine (5.7L, 6.0L, 6.2L and 7.4L) requires a minimum of
87 octane fuel. e octane number is based on the pump octane number,
which is (R + M)/2, where R is the research octane number and M is the
motored octane number.
For better performance, 93 octane fuel is recommended.
87
MINIMUM BETTER BEST
MINIMUM OCTANE RATING
(R + M) / 2 METHOD
91
MINIMUM OCTANE RATING
(R + M) / 2 METHOD
93
MINIMUM OCTANE RATING
(R + M) / 2 METHOD
Fuels other than specied will negatively alter performance and emissions,
and could damage the engine. Use of lower octane fuels will cause spark
knock (pinging). Continued heavy spark knock can cause severe engine
damage. e engines have knock detection systems that oer the best
engine performance by controlling knock through precise ignition timing.
e higher octane fuel will cause less knock for the ignition system to
process and adjust for.
Poor-quality or old fuels can cause problems such as loss of performance,
rough idling, hard starting and hesitation. If the engine experiences any of
these symptoms, rst try another brand of gasoline and/or replace the old
gasoline with fresh gasoline.
Many engine manufacturers believe the U.S. Environmental Protection
Agency’s (EPA’s) detergent levels in gasolines do not provide sucient
deposit controls to allow for optimal engine performance. As a result, TOP
TIER Detergent Gasoline standards were created to ensure gasolines have
all the necessary additives and detergents to reduce the buildup of deposits
in an engine. Ilmor recommends purchasing fuel from a supplier that
conrms its fuel meets TOP TIER specications. For a list of TOP TIER
retailers, check www.toptiergas.com, and click on “Retailers.”
NOTICE: Always use a high-quality gasoline from a reputable source.
Damage to the engine by use of low-quality gasoline or gasoline with an
octane rating below the minimum level listed for Ilmor MV8 engines will
void the warranty on the engine.

ILMOR MV8 Specifications

General

Brand	ILMOR
Model	MV8
Category	Engine
Language	English