ILMOR MV8 - Page 48

SECTION 7 ILMOR MV8 OWNER’S MANUAL
7-2 © 5/2013 Ilmor Marine, LLC, Version 1.0
In addition to the routine matters addressed earlier, there are a number of
other maintenance matters that require periodic attention. e following
table indicates the maintenance schedule:
Item Service
First
25 hrs
Every
50 hrs
Every
100 hrs
Every
300 hrs/
Annually#
Every
Two
Years
Engine oil and filter Change
X X*
Engine coolant Change
X
Power steering fluid**
(if equipped)
Check
X
Transmission fluid Change
X X
Serpentine belt Inspect
X X*** X***
Raw water impeller/sea
pump
Inspect
X X*** X***
Raw water impeller Replace
X X***
Fuel/water separator –
(if equipped)
Replace
X X
High-pressure fuel filter –
(if equipped)
Replace
X X
Air filter/flame arrestor Change
X
Engine timing** Check
X X
Spark plugs** Replace
X
Spark plug wires** Inspect
X
Shaft alignment** Check
X X
Engine and transmission
coolers
Inspect
X
Zinc anodes Clean/Inspect
X
# Whichever comes first.
* If the engine is subject to heavy use, it is recommended to change oil
and filter every 25 hours.
** Services best accomplished by a certified Ilmor dealer.
*** Replace sooner if regular checks indicate wear or damage.
Ilmor recommends that the maintenance requirements be performed by a
certied Ilmor dealer. Service technicians there have the proper equipment,
training and resources to best meet your service needs. Please note that
routine maintenance is not covered by the Ilmor Marine Limited Warranty.
For details, consult the limited warranty statement.