4 Mini-Wave PE4 Installation Guide
Copyright © 2006 Intermatic, Inc.
Contents
Section 1: System Overview .............................................................................................................6
Additional Detail on Key Components .........................................................................................7
24-Volt Valve Actuator (PE24VA) ............................................................................................7
Panel-Mounted Transceiver (PE650) Includes Antenna (PA118) .............................................7
Wireless Hand-Held Transceiver (PE950) ...............................................................................7
Eight-Setting ON/OFF Clock (PB313EK) ..................................................................................8
35-ft. Antenna Extension Cable Assembly (PA121) .................................................................8
OMRON Relay w/24VDC Coil & 2-pin Connector (143T145A) .............................................8
OMRON Relay w/24VAC Coil & 3-pin Connector (PA120) ....................................................8
Water Temperature Sensor (PA122) ........................................................................................9
Optional Transceiver Repeater Module (HA04C) ....................................................................9
Steel Outdoor Enclosure ..........................................................................................................9
Upper or Lower Control Board (PA125) ..................................................................................9
Section 2: Plumbing Examples ........................................................................................................10
For Pool and Spa Combo Installations ........................................................................................10
For Booster Pump Pool Cleaner Installations...............................................................................10
For Non-Booster Pump Pool Cleaner Installations.......................................................................11
Section 3: Control Center Installation ............................................................................................12
Mounting the Control Center ......................................................................................................12
Wiring the System Power ...........................................................................................................12
Bonding the Control Center ........................................................................................................13
Wiring the Individual Equipment ................................................................................................13
High-Voltage Equipment Wiring .................................................................................................13
Wiring Combination 120VAC and 240VAC Equipment Loads ................................................14
Wiring Underwater Lights ..........................................................................................................15
High/Low-Voltage Underwater Lights ....................................................................................15
Low-Voltage Wiring ...................................................................................................................16
Low-Voltage Raceway ...........................................................................................................16
Water Temperature Sensor .....................................................................................................16
Motorized Valve Actuator Connection and Synchronizing .....................................................17
Fireman Switch Connection .......................................................................................................18
Connection for Teledyne Laars Heater ...................................................................................18
Connection for Raypak Heaters .............................................................................................18
Connection for Hayward Heaters ..........................................................................................19
Connection for Pentair Heater ...............................................................................................19
Connection for Sta-Rite Heaters .............................................................................................20
Section 4: Programming the Clock .................................................................................................21
Overview ...................................................................................................................................21
Setting Time of Day ....................................................................................................................21
Programming ON/OFF Settings ..................................................................................................21
Placing the Clock in Timer Mode ................................................................................................22
Overriding the Timer Settings .....................................................................................................22
Changing the Clock Battery ........................................................................................................22
To Next Page
Loading...