Jayco PINNACLE - Page 106

96
FUEL & PROPANE SYSTEM
Propane regulators must always be installed with the regulator vent facing
downward. Regulators that are not located in baggage compartments have
been equipped with a protective cover. Make sure the regulator vent faces
downward and (if applicable) the cover is in place to minimize vent blockage
WKDWFRXOGUHVXOWLQH[FHVVLYHJDVSUHVVXUHFDXVLQJ¿UHRUH[SORVLRQ
9#40+0)
propane components, make sure to always replace them with components of the same type
and rating (check with your dealer).
)LWWLQJVDUHXVHGWRFRQQHFWWKHYDULRXVV\VWHPFRPSRQHQWVWRHDFKRWKHU7KH32/¿WWLQJ
at the end of the propane supply hose is made of brass so that pipe sealants are not necessary
to prevent leaking.
It also has a left-handed thread, which means that it is turned clockwise to remove, and
FRXQWHUFORFNZLVHWRWLJKWHQ7KH32/¿WWLQJKDVEHHQGHVLJQHGWRKHOSUHVWULFWWKHÀRZ
of LP gas in the event of a regulator failure or hose malfunction.
PROPANE REGULATOR
Single stage regulator
Some models are equipped with a single stage regulator.
Two stage regulator
The two-stage regulator has the only moving components in the propane system. Its sole
function is to reduce the pressure from the propane containers to a safe and consistent low
RSHUDWLQJSUHVVXUH7KH¿UVWVWDJHUHGXFHVWKHFRQWDLQHUSUHVVXUHWROEV7KHVHFRQG
stage reduces the 10-13 lbs. of pressure further to an operating pressure of 11” W.C. (water
column) or 6.35 oz. of outlet pressure to your appliances.
7KH VHFRQG VWDJH LV DGMXVWDEOH DQG ZLOO QHHG WR EH DGMXVWHG E\ \RXU GHDOHU RU TXDOL¿HG
propane service technician for optimum performance (this adjustment should always be
made with a properly calibrated manometer).
If the pressure is too high, it affects performance and safety; if the pressure is too low, your
appliances will not operate correctly.
If your recreation vehicle is equipped with the “automatic” two-stage regulator, with both
cylinders full of propane, turn the lever on the regulator towards the cylinder you wish to
XVH¿UVW7KLVZLOOQRZEHWKH³VXSSO\´F\OLQGHUDQGWKHRWKHUWKH³UHVHUYH´6ORZO\RSHQ
both cylinder valves. The indicator on top of the regulator will turn bright green. When the
cylinder becomes empty, the indicator will change to bright orange. Now turn the regulator
lever to the side of the “reserve” cylinder and the green signal should return. You may now
UHPRYH WKHHPSW\ F\OLQGHU WR KDYHLW UH¿OOHG ZLWKRXW LQWHUUXSWLQJWKH ÀRZ IURP WKHIXOO
ERWWOH$IWHU¿OOLQJWKHF\OLQGHUFRQQHFWWKHSLJWDLOKRVHDQGVORZO\RSHQWKHERWWOHYDOYH
USING THE PROPANE SYSTEM
After your recreation vehicle is completely set up use the following steps for propane
operation:
1. Close ALL burner valves, controls and pilot light valves.
2. Open the main valve in the propane tank slowly to avoid a fast rush of propane vapor