Kohler KD440 - OVERVIEW OF PERIODIC MAINTENANCE OPERATIONS; AFTER FIRST 50 HOURS OF OPERATION; Change Oil; Change Oil Bath Filter

7
10 50 250 500
(*)
(*)


 
(**)


(**)
(***)
(°)
- 18 -
MAINTENANCE - RECOMMENDED OIL TYPE - REFILLING
Failure to carry out the operations described in the table may lead to technical damage to the machine
and/or system
MAINTENANCE

          
INTERVAL (HOURS)
 OPERATION COMPONENT
         
   OIL-BATHAIRCLEANER 
  HEADANDCYLINDERFINS
CLEANING  INJECTOR
   
  AIRCLEANEROIL
  LEVEL OILSUMP
CHECK  
  VALVE/ROCKERARMCLEARANCE
  INJECTORSETTING
    AIRCLEANER 
    SUMP   
REPLACEMENT OILFILTERCARTRIDGE
  FUELFILTERCARTRIDGE
  DRYAIRCLEANERCARTRIDGE

(*) Undersevereworkingconditions,cleandaily.
(**) Underextremelydustyconditions,changeevery4-5hours.
(***) Seerecommendedoiltype.
(°)Afterthepolyurethaneprelterhasbeenserviced6-10times(seeg.2for315-350engines),whentheclogging
indicator(ifinstalled)signalsthatthepartmustbereplaced,orifitisirreparablyclogged.
KD 225_315_350_400_440 Workshop Manual_cod. ED0053029330_1° ed_ rev.00
Toavoidexplosionsorreoutbreaks,donotsmokeorusenakedamesduringtheoperations.
Fuelvapoursarehighlytoxic.Onlycarryouttheoperationsoutdoorsorinawellventilatedplace.
Keepyourfacewellawayfromtheplugtopreventharmfulvapoursfrombeinginhaled.Disposeoffuelinthecorrectway
anddonotlitterasitishighlypolluting.
FUEL
Whenrefuelling,itisadvisabletouseafunneltopreventfuelfromspillingout.Thefuelshouldalsobelteredtopreventdustor
dirtfromenteringthetank.
Usethesametypeofdieselfuelasusedincars.Useofothertypesoffuelcoulddamagetheengine.Thecetaneratingofthe
fuelmustbehigherthan45topreventdifcultstarting.Donotusedirtydieselfuelormixturesofdieselfuelandwatersincethis
wouldcauseseriousenginefaults.
Thecapacityofthestandardtankis:
KD225 = l.3.0
KD315 = l.4.3
KD350 = l.4.3
KD400 = l.5.0
KD440 = l.5.0