KYMCO MXU400 - Section 5 - Electrical System

5-1
5
SECTION 5 -
ELECTRICAL SYSTEM
TABLE OF
CONTENTS
Electrical System..................................................... 5-2
Specifications ..........................................................5-2
Battery..................................................................... 5-2
RPM Limiter.............................................................5-2
Testing Electrical Components................................5-2
Accessory Receptacle/Connector........................... 5-2
Brakelight Switch (Pressure)...................................5-3
Oil Temperature and Cooling Fan Switches............5-3
Fan Motor................................................................ 5-4
Fuse Block/Power Distribution Module.................... 5-4
Fuses ...................................................................... 5-5
Ignition Coil ............................................................. 5-5
Speed Sensor ......................................................... 5-6
Ignition Switch .........................................................5-6
Handlebar Control Switches....................................5-7
Front Drive Selector Switch..................................... 5-7
Front Drive Selector Actuator ..................................5-8
Gear Shift Position Switch.......................................5-8
Stator Coil ...............................................................5-9
Starter Relay ........................................................... 5-9
Starter Motor ......................................................... 5-10
CDI Unit................................................................. 5-10
Regulator/Rectifier.................................................5-11
Neutral Start/Front Drive Actuator/Start-in-Gear/
2WD Relays ....................................................... 5-11
Headlights .............................................................5-11
Taillights - Brakelights............................................5-11
Running Lights ...................................................... 5-12
Back-Up Lights......................................................5-12
Ignition Timing....................................................... 5-13
Troubleshooting..................................................... 5-13