Mahindra BFMXTV60 - Troubleshooting Engine and Clutch Problems

25
TROUBLESHOOTING
*Pleaserefertopartsbreakdownsectionforpartsidentification.
PROBLEM POSSIBLECAUSES CORRECTIVEACTION
Accessorystops
working.
Beltisprobablydamagedorbroken Checkandreplacedamagedbelt
Beltissnapping,
shredding,burning
orwornina
specificplace
Accessorywasengagedwhen
clogged
Makesuretheaugerandthefanarenotfrozenor
cloggedbeforeengaging
Lackoftensiononthebelt
Adjustthetensionerspringorreplacespringif
stretched.
Beltshows
prematurewear
Nottheoriginalbelts Alwaysusetheoriginalbelts
Wornbelt,causingaslack. Inspectthebelt.Replaceifrequired.
Imperfectionsinthepulleys
Verifyifthepulleysaredamaged.
Pulleysmustbesmoothwithoutrustspots.Sand
downthepulleysorreplacethem.
Interference
Makesurethebeltdoesnotcomeintocontactwith
anyotherpart,bolts,guidesetc…whenengaged.
Accessorydigs
intoground.
Groundistoosoft. Donotoperateonsoftorwetground.
Theenginedoes
notstart
Theemergencybuttonispushed
down.
Theemergencybuttonmustbepulleduptostart
theaccessory’sengine.
Insufficientelectricalcurrent(A).
Turnkeytothe“OFF”position,checkthebattery
andallotherelectricalconnectionsandinspect
sparkplugandwire.
Theelectromagneticclutchis
activated
Deactivatetheelectromagneticclutch.
Otherreasons.
Seeengine’smanual
Contactenginemanufactureroranauthorizedand
qualifiedmechanic.
Engineisnot
runningwell
Joystickand/orthegascableisnot
welladjusted
Checktheadjustmentofthethrottlelever
Gasisstale
Replacethegas,cleanthegasfilterandthegas
line.Useanappropriategasstabilizer.
Insufficientelectricalcurrent(A). Checkthesparkplugandthehole.
Electricclutchslips
Insufficientelectricalcurrent. Rechargevehicle’sbatteryorreplaceit.
Electricalcurrentiscutoff. Certainwiresaredamagedmustbereplaced.
Theclutchplatesarecontaminated. Cleantheplateswithbrakecleaner.
Electricclutchis
noisyorvibrates
abnormally.
Mountingboltthatholdstheclutch
isloose.
Tightenorreplacebolts.
Certainclutchcomponentsmaybe
damaged.
Repairorreplacedamagedcomponents.