Mahindra BFMXTV60 - TROUBLESHOOTING; Troubleshooting Common Mowing Issues

24
TROUBLESHOOTING
*Pleaserefertopartsbreakdownsectionforpartsidentification.
PROBLEM POSSIBLECAUSE SOLUTION
Reardischargeareais
cloggedup
Thebeltisnotinstalledtherightway Checkbeltinstallation
Grassistoowet Waituntilgrassdries
Grassistootall Raisecuttingheightandcutgrasstwice
Bladesareturningtooslowly Increaseenginespeed
Tractorspeedistoofast Reducetractorspeed
Beltslips
Moweriscloggedup Uncloggandcleanmowerdeck
Pulleysaredirty Removeguardsandcleanthepulleys
Notenoughtensiononbelt Increasebelttension
Thebeltisstretchedanddamaged Changthebelt
Patchesofuncutgrass
Bladesareturningtooslowly Increaseenginespeed
Tractorspeedtoofast Reducetractorspeed
Notenoughtensionontheblet Increasebelttension
Bladesareworndown Sharpenandbalanceorreplacetheblade
Excessivevibration
Oneormorebladesaredamaged Replaceblades
Thebeltisdamaged Changthebelt
Pulleysaremisalignedordamaged Replacepulleysoralignthem
Debrisinthebeltarea
Removebeltguards&cleandebrisfromthebelt
areaandcleanthepulleys
Bladesarescalpingthe
grassinsteadofcutting
it
Thegrassistootall Raisecuttingheightandcutgrasstwice
Themowingpatternisnottheright Changemowingpattern
Tractorspeedtoofast Reducetractorspeed
Bladesarewornout Sharpenandbalanceorreplacetheblade
Unevencut
Tractorspeedtoofast Reducetractorspeed
Themowerisnotlevel Levelthemower
Bladesaredamagedorwornout Replacethebladesorsharpen
Onlythebladesarenot
turning
Notenoughtorqueontheblade'sbolt
Torqueboltaccordingthetorquespecification
table
CAUTION
IF PROBLEMS PERSIST, REFER TO A QUALIFIED MECHANIC TO INSPECT EQUIPMENT. NEVER
ATTEMPTANYADJUSTMENTWHICHYOUARENOTSUREOFGETTINGTHEPROPERRESULTS,THIS
COULDRESULTINFURTHERDAMAGESORPROBLEMS.