11921 Slauson Ave. Santa Fe Springs, CA. 90670 (800) 227-4116 FAX (888) 771-7713
11
PERIODIC MAINTENANCE CHECKLIST
Quarterly or 1250 Cycles (whichever occurs fi
rst)
Semi-annually or 2500 Cycles (whichever occurs fi rst)
NOTE: Make sure vehicle is parked on level ground while performing maintenance
checks.
V
isually check the platform hinge pins for excessive wear and broken welds.
Do the Quarterly or 1250 Cycles Checks on this checklist.
Check the level and condition of the hydraulic ! uid.
Visually check all hoses and " ttings for cha" ng and ! uid leaks. Tighten loose " ttings or
replace parts as required.
Check electrical wiring for cha" ng and make sure wiring connections are tight and free
of corrosion. Use dielectric grease to protect electrical connections.
Check that all WARNING and instruction decals are in place.
Also, make sure decals
are legible, clean, and undamaged.
Check that all bolts, nuts, and roll pins are in place. Make sure roll pins protrude evenly
from both sides of hinge pin collar
. Replace fasteners and roll pins if necessary.
Check for rust and oily surfaces on Liftgate. If there is rust or oil on Liftgate or if the
Liftgate is dirty
, clean it off. Touch up the paint where bare metal is showing. Refer to
the paint system CAUTION and recommended touchup kit on the preceding page.
Check for debris and dirt buildup on the slider rollers and rails. Clean out any buildup of
dirt and debris.
To Next Page
Loading...
