TROUBLESHOOTING
108 eng
Engine Runs Erratically
POSSIBLE CAUSES
•
Guardian System activated. Refer to Features & Controls ‑
Warning System.
• Spark plugs fouled or defective. Refer to Maintenance
section.
• Incorrect setup and adjustments.
• Fuel is being restricted to the engine.
a. Engine fuel filter is obstructed. Refer to Maintenance
section.
b. Fuel tank filter obstructed.
c. Stuck anti‑siphon valve located on permanently built‑in
type fuel tanks.
d. Fuel line is kinked or pinched.
• Fuel pump failure.
• Ignition system component failure.
• Fuel injection component failure (EFI Models).
Engine Overspeed (Excessive RPM)
POSSIBLE CAUSES
• Outboard mounted too high on the transom.
• Worn jet pump impeller or liner.
• Incorrect jet pump impeller clearance adjustment.
• Tilting the outboard out beyond a vertical position.
• Cavitation of the impeller due to rough water or obstruction
in the boat hull.
• Blockage of the water intake.
Performance Loss
POSSIBLE CAUSES
• Throttle not fully open.
• Damaged impeller.
• Incorrect engine timing, adjustments, or setup.
To Next Page
Loading...
