Nice HySecurity CBOX1050 - Page 65

65 pages

Save Page as PDF

To Previous Page

CBOX1050

INSTALLATION AND PROGRAMMING MANUAL

(This page intentionally blank)

www.ApolloGateOpeners.com | (800) 878-7829 | Sales@ApolloGateOpeners.com

Main Page

Table of Contents2
List of Instructions2
Section 1: 1050 Control Box Overview3
1050 Control Board Features3
Section 2: 1050 Control Box Parts Identification5
Section 3: Safety and Ul325 Usage Classes5
Section 4: 120Vac Electrical Wiring Safety10
High Voltage Wire Gauge Requirements11
Section 5: Installation Safety12
Section 6: Tools & Materials Needed12
Control Box Requirements12
Section 7: 1050 Control Box Installation & Setup13
- Instruction 1: Mount Control Box13
- Instruction 2: Wire Actuator(S) to Control Board14
- Instruction 3: Determine Bluebus Photo Eye Locations15
- Instruction 4: Prepare Bluebus Photo Eyes for Install16
- Instruction 5: Install & Wire Bluebus Photo Eyes17
- Instruction 6: Connect Bluebus Photo Eyes to Board18
- Instruction 7: Attach Warning Signs to Gate18
Power Options and Wiring19
- Instruction 8: Battery Power - Input Connections19
- Instruction 9: Main DC Power - Input Connections20
- Instruction 10A: Solar Panel Connections - 10-20W21
- INSTRUCTION 10B: SOLAR PANEL CONNECTIONS - 30W & above22
- Instruction 11: Power up Control Board23
Gate Limit Learning Procedure24
- Instruction 12: Gate Limit Learning Procedure24
- Instruction 13: Select Control Board Standby Mode26
- Instruction 14: Bluebus Photo Eye Status & Troubleshooting27
- Instruction 15: Bluebus Photo Eye Alignment28
- Instruction 16: Bluebus Photo Eye Testing29
- Instruction 17: Bluebus Photo Eye Final Assembly29
- Instruction 18: Installing the Audio Alarm30
- Instruction 19: Assigning New Remote Control31
- Instruction 20: Deleting Single Remote Control32
- Instruction 21: Deleting All Remote Controls32
Section 8: Programming and Controls33
- Instruction 22: Control Board Menu Navigation34
- Instruction 23: 1050 Event Programming Instructions43
- Instruction 24: 1050 Suspend Event Instructions43
Control Board Error Messages & Troubleshooting50
Section 9: 1050 Accessory Connections51
Output Connectors51
Input Connectors53
Emergency Vehicle Access56
Communications Buses57
Section 10: Appendix58
Calculating Solar Requirements58
- Instruction 25: Calculating Solar Requirements58
Maintenance Schedule59
System Troubleshooting60
Installation Checklist61
Part Drawings62
Warranty64

Nice HySecurity CBOX1050 - Page 65

Table of Contents