Paramina CYCLONE SILENT 30E - General Service Instructions

User Manual - Cyclone Silent - 1-2018 edition
PARAMINA SA – Byway Evaggelistrias str. 19300 Aspropirgos, Greece, Tel: 0030 210 5575860-1
Fax: 0030 210 5575868, email: service@paramina.gr - website: www.paramina-compressors.com 42
6.7 General Service Instructions 
o CAUTION: Before any maintenance on the compressor, make sure there is not air inside, under pressure. Every time
you stop the compressor, ALWAYS open the manual drains so as to remove condensate.
o Maintenance must always be done with the compressor stopped and disconnected from the mains supply.
Operating hours
Every 20
hrs
Every 30
hrs
Every
40 hrs
Every 100
hrs
Every
200 hrs
Every
500 hrs
Every 1000
hrs
Every 2000
hrs
Every 6
mths
Every
12 mths
Check
V - Belt tension
1
st
X
Check oil level
1
&
Condensate drain system
Daily
Change of oil
2
1
st
X
X
Replace air intake cartridge
3
X
X
Replace the
BA filter
cartridges
2
Cyclone 24
X
4
X
Cyclone 30
X
4
X
Cyclone 36
X
4
X
Replace coalescing
cartridge
3
X
X
Replace the
Sintered Filter Sponge -Oil
Vapour Exhaust item 10b of
page 63 – concern only some
serial numbers of 2016
X
Check Valves
X
Replace Valves
X
Replace pistons
and piston rings
X
Sintered Filter (Interstage
& Final stage Separator)
6
X
clean
X
replace
Service Kit 1000hrs
5
(p.n.190962400)
X
Service Kit 2000hrs
5
(p.n.190962500)
X
Replace filling hoses
X
Once per
5 years
ATTENTION
1. Check every day the oil level and the general condition of the compressor. Check all connections for leakage.
2. After 6 months, you have to replace the oil and the BA filter’s cartridge(s), whether they have completed the required
operating hours or not. If the compressor is out of operation for a long period of time, you must also replace them before
restart.
 The proper quantity of oil, when you replace it, is 3,0 lit for compressors with serial numbers after / including the
1424012 (CYCL.24E), 1330067 (CYCL.30E) & 1336001 (CYCL.36E). All compressors with earlier serial numbers must be
filled with 2,7 lit oil.
 Never mix different types of oil.
 The compressor unit is delivered filled with PARAMINA HPS OIL (Synthetic oil) with p.n.112001000.
3. After 12 months, you have to replace the coalescing cartridge and the air intake cartridge whether they have completed the
required operating hours or not.
4. Measured @ 20
o
C ambient temperature.
5. Service Kits, o-rings & Teflon may need to be replaced at undefined periods according to several factors.
6. Concerns only compressors equipped with separators part numbers 208501600, 208501610, 208501620 & 208704200.