Pentair Fleck 4650 - CONTROL VALVE DRIVE ASSEMBLY

1
27
20
16
15
19
5
22
17
26
14
18
12
13
31
29
7
21
1
4
3
2
9
6
8
28
10
11
5
23
25
30
BR61501-4650 Rev A
Item No. QTY Part No. Description
1 ................1 ....... 15494-01 ...........“L” Housing - w/Pin
2 ................1 ....... 13175 ................Motor Mounting Plate
3 ................1 ....... 18743-1 .............Motor - 120V, 60 Hz, 1/30 rpm
1 ....... 18752-1 .............Motor - 100V, 50 Hz, 1/30 rpm
1 ....... 18824-1 .............Motor - 23V, 50 Hz, 1/30 rpm
1 ....... 18826-1 .............Motor - 24V, 50 Hz, 1/30 rpm
1 ....... 19659-1 .............Motor - 24V, 60 Hz, 1/30 rpm
1 ....... 19660-1 .............Motor - 230V, 60 Hz, 1/30 rpm
4 ................3 ....... 11384 ................Screw - Motor Mtg. & Ground
Wire
5 ................3 ....... 13296 ................Screw - Component Mounting
6 ................1 ....... 13017 ................Idler Gear
7 ................1 ....... 13018 ................Idler Pinion
8 ................1 ....... 13312 ................Spring - Idler
9 ................1 ....... 13164 ................Drive Gear
10 ..............1 ....... 40214 ................Screw - Brine Cam
11 ..............1 ....... 13170 ................Main Gear & Shaft
12 ..............1 ....... 19205-01 ...........24-Hour Gear Assembly, Silver
13 ..............1 ....... 13011 ................Cycle Actuator Gear
14 ..............1 ....... 14177 ................Knob - Manual Regeneration
15 ..............4 ....... 13300 ................Ball - 1/4" Dia.
16 ..............2 ....... 13311 ................Spring - Detent - Skipper Wheel
17 ..............1 ....... 14207 ................Knob Label - Silver
18 ..............1 ....... 14176 ................Valve Position Dial - Standard
19 ..............1 ....... 14381 ................Skipper Wheel Assembly - 12
Day
1 ....... 14860 ................Skipper Wheel Assembly - 7 Day
20 ..............1 ....... 13864 ................Skipper Wheel Ring
21 ..............2 ....... 14457 ................Spring - Detent - Main Gear
22 ..............1 ....... 13014 ................Regeneration Pointer
23 ..............1 ....... 11842 ................Electrical Cord - Standard
24 ..............2 ....... 12681 ................Wire Connector (Not Shown)
25 ..............1 ....... 13547 ................Strain Relief
26 ..............1 ....... 15151 ................Screw - Knob
27 ..............1 ....... 14331 ................Front Label - Silver on Black
28 ..............1 ....... 12037 ................Washer
29 ..............2 ....... 12473 ................Screw-Drive Mounting
30 ..............1 ....... 60514 ................Brine Cam Assembly, 3-18
1 ....... 60514-01 ...........Brine Cam Assembly, 6-36
1 ....... 60514-02 ...........Brine Cam Assembly, Minutes
31 ..............1 ....... 40327 ................Support Bracket (Hot water Only)
Item No. QTY Part No. Description
CONTROL VALVE DRIVE ASSEMBLY
2 • AP10 Fleck 4650