Perkins 2806A-E18TA - Page 118

Visual Inspection.......................................... 98
Engine Starting.......................................... 17, 42
Engine Stopping........................................ 18, 51
Engine Valve Lash - Check ............................. 98
Engine Valve Rotators - Inspect...................... 98
F
Fan Drive Bearing - Replace ........................... 99
Fault Logging................................................... 40
Features and Controls..................................... 34
Fire Prevention and Explosion Prevention...... 15
Ether ............................................................ 16
Fire Extinguisher.......................................... 16
Lines, Tubes, and Hoses ............................. 16
Fluid Recommendations ........................... 52, 57
ELC Cooling System Maintenance.............. 55
Engine Oil .................................................... 58
General Coolant Information ....................... 52
General Lubricant Information..................... 57
Fluid Recommendations (General Fuel
Information) ................................................... 59
Contamination Control Recommendations for
Fuels .......................................................... 66
Diesel Fuel Characteristics.......................... 61
Diesel Fuel Requirements ........................... 60
General Information..................................... 59
Renewable and Alternative Fuels................ 67
Foreword ........................................................... 4
California Proposition 65 Warning................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 5
Operation ....................................................... 4
Overhaul ........................................................ 5
Safety............................................................. 4
Fuel and the Effect from Cold Weather........... 49
Fuel Conservation Practices ........................... 47
Fuel Related Components in Cold Weather ... 49
Fuel Heaters ................................................ 50
Fuel Tanks ................................................... 49
Fuel System - Prime........................................ 99
2806A and 2806C Fuel Priming .................. 99
2806D Fuel Priming ................................... 100
Fuel System Primary Filter (Water
Separator) Element - Replace..................... 100
2806A and 2806C Primary Filter ............... 101
2806D Primary Filter.................................. 102
Fuel System Primary Filter/Water
Separator - Drain ......................................... 103
2806A and 2806C Water Separator
Drain......................................................... 103
2806D Water Separator Drain ................... 104
Fuel System Secondary Filter - Replace ...... 104
2806A and 2806C Secondary Fuel Filter .. 105
2806D Secondary Fuel Filter..................... 106
Fuel Tank Water and Sediment - Drain ......... 107
Drain the Water and the Sediment ............ 107
Fuel Storage Tanks.................................... 107
Fuel Tank ................................................... 107
G
General Hazard Information............................ 10
Containing Fluid Spillage............................. 12
Dispose of Waste Properly .......................... 14
Fluid Penetration ......................................... 12
Inhalation ..................................................... 13
Pressurized Air and Water............................11
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ....................... 12
General Information ........................................ 20
Grounding Stud - Inspect/Clean/Tighten....... 107
H
Hoses and Clamps - Inspect/Replace........... 108
Fuel System............................................... 109
Replace the Hoses and the Clamps.......... 108
I
Important Safety Information............................. 2
L
Lifting and Storage .......................................... 30
M
Maintenance Interval Schedule........... 71–72, 74
Daily ............................................................. 71
Every 2500 Service Hours........................... 71
Every 3000 Service Hours or 2 Years ......... 71
Every 4000 Service Hours........................... 71
Every 500 Service Hours............................. 71
Every 500 Service Hours or 1 Year ............. 71
Every 6000 Service Hours or 3 Years ......... 71
Every 760 000 L (200 770 US gal) of Fuel or
10 000 Service Hours ................................ 71
When Required............................................ 71
Maintenance Interval Schedule (Engines in
Prime Power Applications with Ratings Greater
Than 635 ekW)
Daily ............................................................. 72
118
SEBU9074-06
Index Section