Perkins 854F-E34T - Drain; Flush

This document is printed from SPI². Not for RESALE
UENR0623 89
Index Section
Index
A
Air in Fuel - Test ............................................... 50
Air Inlet and Exhaust System......................10, 59
Crankcase Breather..................................... 14
Turbocharger................................................ 13
Valve System Components.......................... 14
Air Inlet and Exhaust System - Inspect............ 59
Alternator - Test ............................................... 81
B
Basic Engine.................................................7, 74
Camshaft........................................................ 9
Crankshaft...................................................... 8
Cylinder Block................................................ 7
Cylinder Head ................................................ 7
Gears and Timing Gear Case ........................ 9
Introduction .................................................... 7
Pistons, Rings, and Connecting rods............. 8
Battery - Test.................................................... 83
C
Charging System - Test ................................... 83
Alternator ..................................................... 84
Clean Emissions Module................................. 15
Cleanliness of Fuel System Components........ 20
Cleanliness of the Engine ............................ 20
Environment................................................. 20
New Components ........................................ 20
Refueling...................................................... 20
Compression - Test.......................................... 64
Connecting Rod - Inspect ................................ 75
Cooling System ..........................................17, 70
Coolant Flow................................................ 18
Introduction .................................................. 17
Cooling System - Check .................................. 70
Engine And Cooling System Heat Problems
................................................................... 70
Cooling System - Inspect................................. 70
Visual Inspection Of The Cooling System.... 70
Cooling System - Test...................................... 71
Checking the Filler Cap................................ 71
Making the Correct Antifreeze Mixtures....... 71
Testing The Radiator And Cooling System For
Leaks.......................................................... 72
Crankshaft Pulley - Check ............................... 80
Cylinder Block - Inspect................................... 75
Cylinder Head - Inspect ................................... 75
D
Diesel Particulate Filter - Clean ....................... 63
Cleaning Procedure..................................... 63
Reset the Engine Ash Model ....................... 63
E
Electric Starting System - Test......................... 85
Diagnosis Procedures.................................. 85
General Information..................................... 85
Electrical System........................................19, 81
Alternator ..................................................... 19
Starting Motor............................................... 19
Electronic Control System ............................... 28
Diagnostic Codes......................................... 35
ECM ............................................................. 34
Introduction .................................................. 29
Pressure Sensors ........................................ 38
Sensor Locations for the Clean Emissions
Module ....................................................... 34
Sensor Locations for the Engine.................. 30
Speed/Timing Sensors................................. 36
Temperature Sensors................................... 40
Engine Oil Cooler - Inspect.............................. 72
Engine Oil Pressure - Test ............................... 68
High Oil Pressure......................................... 68
Low Oil Pressure.......................................... 68
Engine Oil Pump - Inspect............................... 68
Engine Operation............................................... 7
Engine Valve Lash - Inspect ............................ 64
Valve Lash Check ........................................ 65
Excessive Bearing Wear - Inspect................... 68
Excessive Engine Oil Consumption - Inspect.. 68
Engine Oil Leaks into the Combustion Area of
the Cylinders .............................................. 68
Engine Oil Leaks on the Outside of the Engine
................................................................... 68
Exhaust Cooler (NRS) - Test ........................... 62
F
Finding Top Center Position for No. 1 Piston... 52
Flywheel - Inspect............................................ 77
Alignment of the Flywheel Face................... 77
Flywheel Runout .......................................... 78