Perkins 904J-E36TA - Page 139

Oil and Filter Change Intervals .................. 120
Replace the Oil Filter Element................... 123
Engine Oil Level - Check................................118
After Operating the Engine .........................119
Before Operating the Engine ......................118
Engine Oil Sample - Obtain............................119
Obtain the Sample and the Analysis ......... 120
Engine Operation ............................................ 63
Carbon Dioxide (CO
2
) Emissions
Statement................................................... 63
Engine Operation and the Aftertreatment
System ....................................................... 63
Engine Operation with Active Diagnostic
Codes ............................................................ 57
Engine Operation with Intermittent
Diagnostic Codes .......................................... 58
Engine Starting.......................................... 22, 59
Engine Stopping........................................ 23, 76
F
Fault Logging................................................... 57
Features and Controls..................................... 43
Fire Prevention and Explosion Prevention...... 18
Ether ............................................................ 19
Fire Extinguisher.......................................... 19
Lines, Tubes, and Hoses ............................. 20
Fluid Recommendations ........................... 79, 91
ELC Cooling System Maintenance.............. 93
Engine Oil .................................................... 80
General Coolant Information ....................... 91
General Lubricant Information..................... 79
Fluid Recommendations (Diesel Exhaust
Fluid (DEF)) ................................................... 90
General Information..................................... 90
Fluid Recommendations (General Fuel
Information) ................................................... 81
Contamination Control Recommendations for
Fuels .......................................................... 89
Diesel Fuel Characteristics.......................... 85
Diesel Fuel Requirements ........................... 82
General Information..................................... 82
Foreword ........................................................... 4
California Proposition 65 Warning................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 5
Operation ....................................................... 4
Overhaul ........................................................ 5
Safety............................................................. 4
Fuel and the Effect from Cold Weather........... 74
Fuel Conservation Practices ........................... 64
Fuel Related Components in Cold Weather ... 75
Fuel Filters ................................................... 75
Fuel Heaters ................................................ 75
Fuel Tanks ................................................... 75
Fuel System - Prime...................................... 124
Electric Fuel Priming Pump ....................... 124
Mechanical Fuel Priming Pump................. 124
Fuel System Primary Filter (Water
Separator) Element - Replace..................... 125
Fuel System Primary Filter (Water Separator)
Element for Electric Fuel Priming Pump.. 125
Fuel System Primary Filter (Water Separator)
Element for Manual Fuel Priming Pump.. 127
Fuel System Primary Filter/Water
Separator - Drain ......................................... 128
Drain Procedure......................................... 128
Fuel System Secondary Filter - Replace ...... 129
Install the Element ..................................... 130
Remove the Element ................................. 129
Fuel Tank Water and Sediment - Drain ......... 130
Drain the Water and the Sediment ............ 130
Fuel Storage Tanks.................................... 131
Fuel Tank ................................................... 130
G
Gauges and Indicators .................................... 44
Aftertreatment Lamps and gauges .............. 46
Indicator Lamps ........................................... 45
General Hazard Information............................ 12
Containing Fluid Spillage............................. 14
Diesel Exhaust Fluid.................................... 16
Dispose of Waste Properly .......................... 16
Fluid Penetration ......................................... 14
Inhalation ..................................................... 15
Pressurized Air and Water........................... 14
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ....................... 14
General Information ........................................ 26
H
High Pressure Fuel Lines ................................ 20
Hoses and Clamps - Inspect/Replace........... 131
Replace the Hoses and the Clamps .......... 131
I
Important Safety Information............................. 2
M0092609-05 139
Index Section