Page 94
TRAVERSE LIFT
Pettibone Michigan, L.L.C. OWNER/OPERATOR MANUAL MODELS 6036/6044/8036/8044
SERVICE AIR CLEANER
1. Loosen the cup assembly retaining clamp and remove the cup assembly from the air
cleaner housing.
2. Remove the wing nut from the center post of the air filter housing and remove the primary
filter element.
CAUTION
Remove the safety element only if it is to be replaced. DO NOT attempt to clean the
safety element. If the safety element is to be replaced, immediately install a new
element in its place to prevent contaminants from entering the engine.
3. Remove the wing nut from the center post of the canister and remove the safety element.
4. Install the safety element immediately by positioning it in the air cleaner housing and
installing the wing nut.
5. Gently pat the sides of the primary element to loosen dirt. DO NOT tap the element
against a hard surface.
CAUTION
When using compressed air to clean the element, make certain the air pressure is less
than 30 psi. Clear the area of bystanders, guard against flying chips and wear proper
protective safety equipment, including eye protection.
6. Clean the primary element from the inside with compressed air. Hold the nozzle next to
the inner surface and move up and down pleats. Repeat as necessary until clean.
7. If necessary, wash the primary element, as follows:
a. If the element is coated with oil or soot, wash it in a solution of warm water and filter
element cleaner. Let the element soak at least 15 minutes, then agitate gently to flush
out dirt.
b. Rinse the element thoroughly from the inside with clean water. Keep the water pressure
under 40 psi to avoid damaging the filtering pleats.
c. Allow the element to dry completely before using. This usually takes from one to three
days. Do not oven dry or use drying agents. Protect the element from freezing until it is
dry.
8. Inspect the primary element as follows:
a. Hold a bright light inside the filter element and check it for holes. Discard the filter
element if holes are found.
Continued on next page
To Next Page
