Automatic boiler for wood pellets
Instructions for installation and operation
TABLE OF CONTENTS:
1. IMPORTANT NOTICES 4
2. USE OF THE BOILER AND ITS ADVANTAGES 5
3. TECHNICAL DATA OF THE BOILERS KP 11, KP 11E, KP 21, KP 21E 6
4. STRUCTURAL DESCRIPTION OF PRODUCTS 7
4.1 BOILER BODY 7
4.2 CONTROL UNIT OF THE BOILER 10
4.2.1 Connection of connectors of the control unit 11
4.2.2 Block diagram of the control unit 12
4.2.3 Description of the control panel 13
4.2.4 Block diagram of operation of the control unit 14
4.2.5 Manual control 15
4.2.6 Automatic operation 15
4.2.6 Main menu 16
4.3 BURNER FURNACE INCLUDING THE FEEDER 2 19
4.4
CERAMIC PARTS 20
4.5 FEEDER 1 WITH INDEPENDENT DRIVE 20
4.6 JACKETING OF THE BOILER INCLUDING HEAT INSULATION 20
4.7 STANDARD ACCESORIES 20
4.8 OPTIONAL ACCESSORIES 21
4.9
FUEL BIN 22
5.
PLACEMENT OF THE PRODUCT IN BOILER ROOMS, PRINCIPLES OF INSTALLATION 22
5.1 PLACEMENT OF PRODUCTS IN BOILER ROOMS 22
5.2 SAFE DISTANCE FROM COMBUSTIBLE MATERIAL 22
5.3 LEGISLATION IN FORCE 22
5.3.1 Heating system and boiler 23
5.3.2 Venting 23
5.3.3 Fire regulations 23
5.3.4 Electrical 23
5.3.5 Noise control 23
5.4
STORAGE OF FUEL 24
5.5
BOILER ROOM VENTILATION 24
6.
PUTTING THE PRODUCTS INTO OPERATION 24
6.1 CONNECTION TO THE SYSTEM 24
6.2 INSTALLATION OF THE CERAMIC CATALYTIC REFLECTOR 25
6.3 INSTALLATION OF THE CERAMIC EXTENSION GRATE 26
6.4 FITTING THE CERAMIC SHIELD 26
6.5 CHECKS BEFORE THE BOILER IS PUT INTO OPERATION 27
6.6 IGNITION 27
6.7 AUTOMATIC OPERATION 29
6.8 SELECTION OF THE REQUIRED HEAT OUTPUT OF THE BOILER 29
6.9 ELECTRIC MODERATE HEATING 29
7.
MAINTENANCE AND ATTENDANCE OF THE BOILER DURING OPERATION 30
7.1 ATTENDANCE 30
7.2 MAINTENANCE 31
7.3 ANNUAL AUDIT 32
7.4 OPERATING STATES – BASIC FIGURE 34
8.
FAILURE STATES 34
8.1 STOP STATE - DUE TO OVERHEATING 34
8.2 STOP STATE - DUE TO WATER TEMPERATURE DROP 35
8.3 STOP STATE - BLOCKED FEEDER 35
8.4 LACK OF PELLETS IN THE FUEL BIN 36
8.5 ELECTRICITY SUPPLY INTERRUPTION 36
9. DISPOSAL OF PRODUCT AFTER THE END OF ITS SERVICE LIFE 36
9.1 NATURAL PERSON 36
9.2 LEGAL ENTITY 37
2
To Next Page
Loading...
