Pulsar PG1202S - User Manual

Other manuals for Pulsar PG1202S

Questions and Answers:

H
Heather GreenJul 27, 2025
What to do if my Pulsar Inverter engine will not start?
- M
  Margaret GillJul 27, 2025
  If your Pulsar Inverter engine won't start, shuts down, or runs rough, try the following: * Ensure the switch is in the “ON” position. * Replace the air filter. * Clean or replace the fuel filter. * Replace the fuel. * Reconnect the spark plug wire. * Replace the spark plug. * Drain the fuel tank and replace the fuel. * Ensure the fuel valve is in the “ON” position. * Turn off the choke. * Wait 5 minutes and recrank the engine.
J
Jesus WaltonAug 1, 2025
Why does my Pulsar Inverter engine lack power?
- J
  Joseph SmithAug 1, 2025
  If your Pulsar Inverter engine lacks power, make sure you are not overloading the generator. Also, try cleaning or replacing the fuel filter and replacing the air filter.
C
Christopher HendersonAug 8, 2025
What to do if Pulsar Inverter engine runs well without load but bogs down when loads are connected?
- P
  Paul HendersonAug 8, 2025
  If your Pulsar Inverter engine runs well without a load but bogs down when loads are connected: * Disconnect the device. * Avoid overloading the generator. * Clean or replace the fuel filter.
J
johnsonsusanAug 13, 2025
How to fix Pulsar Inverter when engine is running, but AC output is not available?
- D
  dennis00Aug 13, 2025
  If the engine of your Pulsar Inverter is running but there is no AC output, try the following: * Reset the circuit breaker. * Check and repair the device. * Connect a device that is working properly.
S
Stacy KaiserAug 19, 2025
How to resolve Pulsar Inverter engine “hunts” or falters?
- M
  Mathew GonzalesAug 19, 2025
  To resolve an engine that “hunts” or falters on your Pulsar Inverter, move the choke to the middle position until the engine runs evenly. You can also try cleaning or replacing the fuel filter.

Pulsar PG1202S Specifications

General

Model	PG1202S
Type	Portable Generator
Starting Wattage	1200 W
Running Wattage	900 W
Fuel Type	Gasoline
Runtime at 50% Load	8 hours
AC Voltage	120 V
Engine Displacement	63 cc
Starting System	Recoil
Engine Type	4-stroke, OHV
Outlet	1 x 120V AC
Noise Level	68 dB(A)

Summary

INTRODUCTIONS

Product Specifications

Details about the generator's technical capabilities and performance metrics.

How to contact us

Information on reaching customer support or service.

SAFETY RULES

Safety Symbols

Explanation of warning and caution symbols used in the manual.

Safety Instructions

Crucial guidelines for safe operation, handling, and maintenance.

FEATURES

ASSEMBLY

Unpacking

Steps to unbox the generator and check for all components.

Packing List

List of items included in the generator package.

Installing the Handle

Instructions for attaching the generator's carrying handle.

Generator Operation Procedures

Grounding the Generator

Essential steps for safely grounding the generator to prevent electrical hazards.

How to Start Engine

Step-by-step guide to safely start the generator engine.

OPERATION

How to Stop Engine

Procedure for safely shutting down the generator.

Receptacles and Extension Cords

Guidelines for using extension cords and generator outlets.

Continued Operation Guidelines

Extension Cord Selection

Recommendations for choosing appropriate extension cords based on load and distance.

Moving the Generator

Safe procedures for relocating the generator.

Load Management and Usage

Dont Overload Generator

Instructions to prevent exceeding the generator's power capacity.

Wattage Reference Guide

Chart of typical wattage requirements for common appliances.

Advanced Operation

Power Management

Tips for optimizing power output and load distribution.

Cold Weather Operation

Precautions and steps for operating the generator in cold temperatures.

MAINTENANCE

Pre-Operation Steps

Checks to perform before starting the generator.

After Each Use

Post-operation procedures and storage recommendations.

Maintenance Schedule

Recommended service intervals and tasks for upkeep.

Maintenance Details

Air Filter

Instructions for cleaning or replacing the air filter.

Checking Spark Plug

Procedure for inspecting and maintaining the spark plug.

Draining Fuel Tank and Carburetor

Steps for draining fuel for storage or maintenance.

Storage and Long-Term Care

Storage and Transportation of the Generator

Guidelines for safely storing and moving the generator.

Engine Long Term Storage

Specific procedures for preparing the engine for extended storage.

DIAGRAMS

TROUBLESHOOTING

WARRANTY

Pulsar Products Inc Limited 1 Year Warranty

Details of the manufacturer's limited warranty coverage.

Length of Warranty

Information on the duration and terms of the warranty.

Consumer Responsibilities

Obligations of the owner for warranty validity and service.

Warranty Exclusions and Validity

What this Warranty Does Not Cover

List of conditions and parts not protected by the warranty.

Where Warranty is Valid

Information on the geographical and purchase channel validity of the warranty.

SPECIFICATIONS

DIMENSIONS

Physical measurements of the generator unit.

ENGINE

Technical specifications related to the generator's engine.

GENERATOR

Technical specifications related to the generator's electrical output.

PARTS LIST

Cylinder Head System Assy

Diagram and parts list for the cylinder head assembly.

Cylinder Barrel

Diagram and parts list for the cylinder barrel assembly.

Piston and Crankshaft Connecting Rod System Assy

Diagram and parts list for the piston and crankshaft assembly.

Recoil Starter System Assy

Diagram and parts list for the recoil starter system.

Carburetor System Assy

Diagram and parts list for the carburetor assembly.

Flywheel System Assy

Diagram and parts list for the flywheel assembly.

Ignition System Assy

Diagram and parts list for the ignition system.

Control System Assy

Diagram and parts list for the control system.

Muffler System Assy

Diagram and parts list for the muffler assembly.

Fuel System Assy

Diagram and parts list for the fuel system components.

Control Box Assy

Diagram and parts list for the control box components.

Generator Assy

Diagram and parts list for the generator assembly.

Related product manuals