The Periodical maintenance schedule detailed below is based upon average riding conditions and indicates the Intervals at which
regular inspections, adjustments, replacements and lubrications must be carried out to help maintain your motorcycle meticulously.
If in case the motorcycle is used frequently in very dusty environment / severe climatic conditions / Poor Roads / stagnant water etc.,
the maintenance will need to be done earlier as may be required.
Contact a nearest Royal Enfield Authorized Dealer / Service Center to carry out the periodical maintenance and for any expert advice.
A : Adjust C : Clean D : De-carbonise I : Inspect L : Lubricate R : Replace
S.
No.
DESCRIPTION
SCHEDULE
SECTION 02 - PERIODICAL MAINTENANCE
NOTE :
For maintenance after 30,000 Kms, (18,750 miles) please repeat the same frequency levels specified above, in consultation with a
Royal Enfield Authorized Dealer.
BULLET CLASSIC EFI & BULLET EFI
Kms (x 1000) 0.5 3 6 9 12 15 18 21 24 27 30
Miles (x 1000) 0.3 2 3.75 6 7.5 9.5 11.25 13 15 17 18.75
1 Engine Oil
R R R R R R
Check level every 500 Kms or earlier as required
2 Engine oil filter element R R R R R R
3 Engine sump filter (oil strainer) C C C C C C
4
Magnetic drain plug under gear box and secondary C C C C C C
drain plug under crankshaft in crankcase right
5 Spark plug A A A A A R A A A A R
6 HT lead I I I I I I I I I I I
7 Fuel hose I I I I R I I I R I I
8 Fuel Pump Check for screw tightness in all services
9 Accelerator cable play A A A A A A A A A A A
10 Rubber hose, Air filter to Throttle body I I I I R I I I R I I
11 Rubber hose, Inlet manifold / Adaptor I I I I R I I I R I I
12 Airfilter paper element C C C C R C C C R C C
13 Inlet/Exhaust valve seating (compression/vaccum test) I I
14 Cylinder head D
15 Exhaust system D
16 Clutch free play Adjust every 1000 Kms or earlier as required
17 Rear brake pedal pivot L L L L L L L L L L L
18 Battery terminals (apply petroleum jelly) C C C C C C C C C C C
19 Battery Electrolyte level I I I I I I I I I I I
20 Earth wire eyelet (behind battery carrier) I I
21 Rear Wheel Drive Chain
Lubricate & Adjust every 1000 Kms/Clean, Lubricate &
Adjust every 3000 Kms or earlier as required
22 Front Fork oil R R R
23 Rear brake play Adjust every 1000 Kms or earlier as required
24 Rear brake cams L L L L L
25 Steering ball races play I A L A L A L A R A L
26 Spokes tightness / Wheel rim run out front & rear I I I I I I
27 Pivot-Side Stand, Center Stand, Pillion Foot Rest L L L L L L L L L L L
28 Tyre wear pattern (Front & Rear) I I I I I I I I I I I
29 Hand levers pivot Lubricate every 1000 Kms or earlier as required
30 Front Disc Brake Oil level check I I I I I R I I I I R
31 Evaporative Emission Equipment rubber hoses I I I I R I I I R I I
ROYAL ENFIELD VEHICLE SERVICE MANUAL - EURO IV
06
To Next Page
Loading...
Need help?
General
