Samsung ML-2150 - Page 126

Exploded Views & Parts List
Samsung Electronics
Service Manual
8-13
Fuser Unit Assembly Parts List(1/2)
No. Location Description SEC.Code Q’ty SA Remark
0 F4068 ELA UNIT-FUSER_25 ; ML-2550,XEROX,USA,110V JC96-02693C 1 O 110V
ELA UNIT-FUSER_25 ; ML-2550,XEROX,USA,220V JC96-02693D 1 O 220V
1 W3182 ELA UNIT-UPPER FUSER ; ML-2150,SEC,USA JC96-02694A 1 X
1-1 F4127 THERMISTOR-NTC ; 7KOHM,-,3370K,0.3MW/C 1404-001305 1 O
1-2 S2003
SCREW-ASSY MACH ; WSP,PH,+,M3,10,ZPC(YEL) 6006-001193 2 X
1-3 N1000 NUT-HEX ; 2C,M3,ZPC(YEL),SM20C 6021-000222 2 O
1-5 Z4107 SPRING-TS ; SUS304,-,PI0.6,D3.6,L22,-,W20 6107-001156 2 O
1-7 K4279 THERMOSTAT-150 ; ML-1510,-,125/250V,15/7.5 JC47-00005A 1 O
1-8 Z4254
SPRING-SAPERATION ; ML-165,SUS304 WPB,PI0 JC61-70909A 5 O
1-9 Z2194 COVER-M-FUSER ; ML-2060,PET+GF30%+MD JC63-00110A 1 O
1-10 S4049 IEX-SHAFT IDLE,F/UP ; ML-5000A,SUS304,PI1 JC70-20901A 2 O
1-11 E0001
ELECTRODE-P-FU_M ; ML-2060,T0.6,6,L72,C521 JC71-00039A 1 O
1-12 E0002 ELECTRODE-P-FU_R ; ML-2060,T0.6,6,L72,C521 JC71-00040A 1 O
1-13 E0000 ELECTRODE-P_FU_L ; ML-2060,T0.6,6,L90,C521 JC71-00041A 1 O
1-14 K3804 PEX-ROLLER F/UP(2) ; ML-5000A,TE JC72-20902A 2 O
1-15 K4068
PMO-ROLLER UPPER DP ; ML-165,POM,WHT,HB JC72-40981A 2 O
1-16 C7003 PMO-GUIDE CLAW ; ML-165,PEEK,BLK JC72-41012A 5 O
1-17 B5010 MEC- BRUSH ANTISTATIC ; ML-6060A,SEC,NTR JC75-00095A 1 O
1-18 H4027 HOLDER-M-IDLE ROLLER;ML-2150,PC,BL JC61-00785A 2 O
1-19 C1015 CAP-M-FUSER_L ; ML-2550,OFL4036,T1.5,B JC67-00056A 1 X
1-20 C1016 CAP-M-FUSER_R ; ML-2550,OFL4036,T1.5 JC67-00057A 1 X
2 F4020 MEA UNIT-LOWER FUSER ; ML-2150,SEC,USA JC97-01718A 1 X
2-2 Z4230 SPRING-PR(7300) ; ML-7300,PIANO WIRE,1.0,6 JC61-00056A 2 O
2-3 K2881 BUSH-M-HR_R ; ML-2060,PPS,BLK JC61-00615A 1 O
2-4 F4084 GEAR-FUSER 7300 ; ML-7300,PPS, OFL4036,1,3 JC66-40913B 1 O
2-5 F2122 FRAME-P-FUSER ; ML-2060,SECC T1.2 JC61-00621A 1 O
2-6 H2010
ROLLER-HEAT ; ML-2150,AL PIPE T1.8MM,26MM JC66-00597A 1 O
2-7 P6014 ROLLER-PRESSURE ; ML-2150,HTV SP JC66-00599A 1 O
2-8 P6004 BEARING-PRESSURE/R ; ML-165,PPS,5,4.8 JC66-10901A 2 O
2-9 B1019 BEARING-H/R L ; ML-165,PPS(RBA313),ID26.2 JC66-10902A 1 O
2-10 K2680 SPACER-DEV ; ID6.0,OD19.6,T0.2,NTR,TEFLON JC60-40902A 2 X
3 K3570 MEA UNIT-GUIDE REAR ; ML-2150,SEC,USA JC97-01719A 1 X
3-1 G2074 GUIDE-M-REAR ; ML-2060,PET+GF30%+MD JC61-00620A 1 O
3-2 Z4132 SPRING-ACTUATOR ; ML-165,SWPB,P0.15,D7,L1 JC61-70903A 1 O
3-3 S4119 SHAFT-M-EXIT_F/UP ; ML-2060,PC JC66-00402A 1 O
3-4 E4041 GEAR-EXIT ; ML-80,POM,BLK JC66-40209A 1 O
3-5 L0213
LABEL(R)-CAU_HOT_FU ; ML-5000A/XRX,PVC,40X JC68-30928B 1 X
3-6 B6027 PMO-BUSHING TX ; ML-6060A,POM,BLK JC72-00382A 3 X
3-7 E4093 PMO-ACTUATOR EXIT ; ML-2060,PC,BLK JC72-00988A 1 O
3-8 E4158 RMO-RUBBER EXIT_F/UP ; ML-2150,EPDM JC73-40909B 2 X
SA : Service Available
O
: Service available X : Service not available