Sony HCD-RV660D User Manual

1
Ver 1.3 2004. 09
DVD
Model Name Using Similar Mechanism NEW
Section
DVD Mechanism Type CDM74S-DVBU23
Optical Pick-up Name DBU-1
Tape Deck Model Name Using Similar Machanism HCD-RG550
Section Tape Transport Mechanism Type CWM43RR-23
SERVICE MANUAL
E Model
Australian Model
HCD-RV660D/RV990D
Amplifier section
The following measured at AC 120, 127, 220, 240 V,
50/60 Hz
Continuous RMS power output (reference)
Front speaker: 100 + 100 watts
(6 ohms at 1 kHz, 10%
THD)
Center speaker*: 40 watts (8 ohms at 1 kHz,
10% THD)
Surround speaker*: 40 + 40 watts
(6 ohms at 1 kHz, 10%
THD)
* MHC-RV990D only
Inputs
MD/VIDEO (AUDIO) IN (phono jacks):
voltage 450/250 mV,
impedance 47 kilohms
GAME (VIDEO) IN (phono jack):
1 Vp-p, 75 ohms
GAME (AUDIO) IN (phono jack):
voltage 250 mV,
impedance 47 kilohms
MIC (phone jack): sensitivity 1 mV,
impedance 10 kilohms
Outputs
MD/VIDEO (AUDIO) OUT (phono jacks):
voltage 250 mV,
impedance 1 kilohm
VIDEO OUT (phono jack):
max. output level
1 Vp-p, unbalanced, Sync
negative, load impedance
75 ohms
SPECIFICATIONS
S-VIDEO OUT (4-pin/mini-DIN jack):
Y: 1 Vp-p, unbalanced,
Sync negative,
C: 0.286 Vp-p, load
impedance 75 ohms
COMPONENT VIDEO OUT:
Y: 1 Vp-p, 75 ohms
PB, PR: 0.7 Vp-p, 75 ohms
PHONES (stereo mini jack):
accepts headphones of
8 ohms or more
Front speaker: Use only the supplied
speaker SS-RV990
Surround speaker (except for MHC-RV660D):
Use only the supplied
speaker SS-RS390
Center speaker (except for MHC-RV660D):
Use only the supplied
speaker SS-CT390
SUB WOOFER OUT: voltage 1 V,
impedance 1 kilohm
Sony Corporation
Audio Group
Published by Sony Engineering Corporation
9-961-078-04
2004I04-1
© 2004. 09
– Continued on next page –
DVD DECK RECEIVER
• HCD-RV660D/RV990D are the
tuner, deck, DVD and amplifier
section in MHC-RV660D/RV990D.
(Photo: HCD-RV990D)

Sony HCD-RV660D Specifications

General

Tuner Type	FM/AM
CD Player	Yes
USB Playback	Yes
Bluetooth	No
Audio Channels	2.0
Remote Control	Yes
Power Output	100W
Inputs	USB, AUX
Outputs	Headphone Jack
Type	Mini Hi-Fi System

Summary

SPECIFICATIONS

Amplifier section

Describes electrical characteristics.

Disc player section

Tape deck section

Tuner section

Notes on Chip Component Replacement

CAUTION

MODEL IDENTIFICATION

Laser Diode and Focus Search Operation Check

SECTION 1 GENERAL

Main Unit

Describes the main components and controls of the unit.

Remote control

SECTION 2 DISASSEMBLY

2-1. CASE

Procedure for removing the outer case of the unit.

2-3. FRONT PANEL SECTION

Procedure for removing the front panel assembly.

2-4. DVD BLOCK SECTION

Procedure for removing the DVD mechanism block.

2-9. MAIN BOARD (HCD-RV990D)

Procedure for removing the main board for HCD-RV990D.

SECTION 4 EXPLODED VIEWS

4-1. MAIN SECTION

Exploded view of the main unit components.

4-2. FRONT PANEL SECTION (1)

4-3. FRONT PANEL SECTION (2)

4-4. FRONT PANEL SECTION (3)

4-5. DVD BLOCK SECTION

4-6. MAIN BOARD SECTION (1/2)

4-7. MAIN BOARD SECTION (2/2)

4-8. DVD MECHANISM DECK SECTION (1)

4-9. DVD MECHANISM DECK SECTION (2)

SECTION 5 ELECTRICAL PARTS LIST

CAPACITOR

List of capacitors with part numbers and specifications.

SUPPLEMENT-1

1. SERVICE POSITIONS

Details service access points for key components.

2. TEST MODE

Guide to entering and using the diagnostic test modes.

3. MECHANICAL ADJUSTMENTS

Procedures for mechanical adjustments and torque specifications.

4. ELECTRICAL ADJUSTMENTS

Procedures for electrical adjustments and checks.