Stihl MSA 160 C User Manual (English)

Questions and Answers:

C
charles75Aug 29, 2025
What to do if LED on Stihl MSA 160 C Chainsaw charger flashes red?
- J
  james77Aug 29, 2025
  If the LED on your Stihl Chainsaw charger flashes red, the problem could be: * No electrical contact between the charger and the battery. Try removing the battery and refitting it. * A malfunction in the battery (4 LEDs on the battery flash red for about 5 seconds). Remove the battery, refit it, and switch on the machine. If the LEDs continue to flash, the battery has a malfunction and must be replaced. * A malfunction in the charger. Have the charger checked by a servicing dealer.
S
Shannon MurphyAug 28, 2025
Why is the Stihl Chainsaw runtime too short?
- C
  Carol SmithAug 28, 2025
  If your Stihl Chainsaw's runtime is shorter than expected, it could be due to a couple of reasons. First, make sure the battery is fully charged by following the instructions in the STIHL AL 101, 300, or 500 charger's manual. If the battery has reached the end of its normal life, consider replacing it with a new one.
N
Nicole DunnAug 28, 2025
Why does my Stihl MSA 160 C have a smoke or burning smell?
- K
  kristylynnAug 28, 2025
  If you notice smoke or a burning smell while using your Stihl chainsaw, several factors could be the cause. First, ensure that the chain is properly sharpened. If the chain oil tank is low, refill it. Also, check the chain tension and adjust if it's over-tensioned. If the chain lubrication system isn't working correctly, or you are not using the chainsaw properly, stop using the saw and seek assistance from your Stihl servicing dealer to prevent further issues.
S
Stephen ThomasAug 27, 2025
Why is the running time too short on my Stihl Chainsaw?
- J
  Joanne MiddletonAug 27, 2025
  There are several reasons why your Stihl Chainsaw's running time might be shorter than expected. The most common cause is an incompletely charged battery, so ensure the battery is fully charged before use. Also, a dirty cutting attachment can reduce running time, so keep it clean. The battery's service life may also be reached or exceeded, requiring a check and potential replacement.
T
Thomas JohnsonAug 27, 2025
What to do if my Stihl Chainsaw switches off during operation?
- J
  Jeanette RiosAug 27, 2025
  If your Stihl Chainsaw switches off during operation, it could be due to the battery or machine electronics overheating. Remove the battery and allow both the battery and the machine to cool down. Another potential cause is an electrical or electromagnetic malfunction. Try removing the battery and then reinserting it to see if this resolves the issue.
S
Samantha ZimmermanAug 25, 2025
What to do if my Stihl MSA 160 C Chainsaw cuts out during operation?
- P
  Paul LuceroAug 26, 2025
  If your Stihl Chainsaw cuts out during operation, it could be due to the following reasons: * The battery or the machine's electronics may be too hot. To resolve this, take the battery out of the machine and allow both the battery and the machine to cool down. * There may be an electrical or electromagnetic malfunction. Try removing the battery and then refitting it to see if this resolves the issue.
T
Teresa GriffithSep 10, 2025
Why is my Stihl MSA 160 C battery not being charged even though LED on charger glows green?

Stihl MSA 160 C Specifications

General

Voltage	36 V
Bar Length	12 in
Chain Gauge	0.043 in
Power Source	Battery
Bar Length (cm)	30 cm
STIHL Oilomatic saw chain type	Picco Micro 3 (PM3)
Sound Power Level	96 dB(A)
Chain Pitch	0.25 in
Recommended Battery	AP 300
Recommended Charger	AL 300