Suzuki DF140WT User Manual

PERIODIC MAINTENANCE 2-17
HIGH PRESSURE FUEL FILTER
Replace every 1000 hours.
SUZUKI recommends that high pressure fuel filter be replaced
every 1000 operating hours.
WATER PUMP / WATER PUMP IMPELLER
WATER PUMP
Inspect every 200 hours (12 months).
Inspect case and under panel.
Replace If wear, cracks, distortion or corrosion is found.
WATER PUMP IMPELLER
Replace every 200 hours (12 months).
Inspect water pump impeller.
Replace if vanes are cut, torn or worn.
PROPELLER / NUT / COTTER PIN
Inspect initially after 20 hours (1 month) and every 100
hours (6 months).
• Inspect propeller for bent, chipped or broken blades.
Replace propeller if damage noticeably affects operation.
• Inspect propeller splines. Replace propeller if splines are
worn, damaged or twisted.
• Inspect propeller bush for slippage.
Replace if necessary.
• Make sure that propeller nut is torqued to specification and
cotter pin is installed securely.

Suzuki DF140WT Specifications

General

Max Power	140 HP
Gear Ratio	2.59:1
Starting System	Electric
Steering	Remote
Number of Cylinders	4
Alternator Output	12V 40A
Trim Method	Power Trim and Tilt
Exhaust	Through propeller
Displacement	2, 044 cc
Shaft Length	20 in
Oil Capacity	5.0 L
Engine Type Detail	4-Stroke
Engine Type	4-Stroke DOHC 16-Valve
Fuel System	Multi-point sequential electronic fuel injection