Tennant T300e - Service Information Manual

128 pages

Save Page as PDF

To Next Page

T300

T300e

Automatic Floor Scrubber

English EN

Service Information Manual

9014510

Rev. 01 (3-2017)

*9014510*

For the latest Parts Manuals and other

language Operator Manuals, visit:

www.tennantco.com/manuals

Hygenic

Fully cleanable

Recovery Tank

TennantTrue

Parts

IRIS

a Tennant Technology

Main Page

Introduction2
Intended Use2
Machine Data2
- Serial Number Location2
- Uncrating Machine2
- Table of Contents3
Contents3
Safety Precautions6
General Information10
- Component Locator10
- Electrical Schematic Symbols11
- Electrical Schematic T300 (Drive Model) - 1 of 312
- Electrical Schematic T300 (Push Model) - 1 of 315
- Electrical Schematic T300E (Drive Model) - 1 of 218
- Electrical Schematic T300E (Push Model) - 1 of 220
- Fastener Torque23
- Sae (Standard)23
- Metric23
- General Machine Dimensions/Capacities/Performance24
- General Machine Dimensions/Capacities/Performance25
- General Machine Dimensions/Capacities/Performance26
- General Machine Dimensions/Capacities/Performance27
Maintenance32
- Maintenance Chart32
- Machine Maintenance33
- After Daily Use33
- After Weekly Use35
- After Every 50 Hours of Use36
- After Every 100 Hours of Use36
- Electric Motors37
- Belts37
- Orbital Scrub Head Isolators (Lower)37
- Batteries38
- Maintenance-Free Batteries38
- Flooded (Wet) Lead-Acid Batteries38
- Checking Connections / Cleaning38
- Charging Batteries39
- Squeegee Blade Replacement40
- Ec-H2O Nanoclean Water Conditioning Cartridge Replacement41
Loading/Unloading Machine for Transporting42
Storing Machine43
Freeze Protection43
Troubleshooting44
Faults44
Faults - off Board Battery Charger57
Troubleshooting58
Onboard Battery Charging on (Option)60
Batteries Failed to Charge/ Reduced Run Time (Onboard Charger)61
Off Board Battery Charging on (Option)62
Batteries Failed to Charge/ Reduced Run Time (off Board Charger)63
Power-Up on64
Machine Failed to Power up65
T300 Propel Subsystem (Option)66
T300 Failed to Propel67
T300E Propel Subsystem (Option)68
T300E Failed to Propel69
T300 Scrub Motor on70
T300 Scrub Motor Failed to Turn on71
T300E Scrub Motor on72
T300E Scrub Motor Failed to Turn on73
Scrub Head Lift Actuator (Option)74
Scrub Head Failed to Raise/Lower75
T300 Vacuum Fan on76
T300 Vacuum Fan Failed to Turn on77
T300E Vacuum Fan on78
T300E Vacuum Fan Failed to Turn on79
T300 Solution Control on (Conventional)80
T300 Solution Control Failed to Turn on (Conventional)81
T300E Solution Control on (Conventional)82
T300E Solution Control Failed to Turn on (Conventional)83
T300 Solution Control on (Ec-H2O)84
T300 Solution Control Failed to Turn on (Ec-H2O)85
T300E Solution Control on (Ec-H2O)86
T300E Solution Control Failed to Turn on (Ec-H2O)87
T300 Se (Severe Environment) on88
T300 Se (Severe Environment) Failed to Turn on89
Sun-I/O Circuit Board Testing (Universal Schematic)90
Sun-I/O Circuit Board Testing Procedure91
Can Open Network Issues92
Connectors Fully Seated92
Pin Fully Seated92
Network Resistance92
Node (Module) Resistance93
Wire Continuity to Node93
Machine Node Table94
Service95
Service Diagnostics Tool95
Programing a New Interface Module95
Re-Configuring Existing Modules97
Programming the I-Drive Module (Option)99
Displaying Fault Codes100
Battery Charger Settings101
Off-Board Battery Charger101
Changing Off-Board Battery Charger Settings101
On-Board Battery Charger103
Changing On-Board Battery Charger103
- Settings (Pro-Membrane Model)103
Changing On-Board Battery Charger104
- Settings (Pro-Panel Model)104
Battery Charger Operation105
Removing Scrub Head Assembly106
Installing Scrub Head Assembly107
Checking and Adjusting Cylindrical Scrub Brush Pattern107
Removing Lower Orbital Head Isolators110
Installing Lower Orbital Head Isolator111
Removing Transaxle Assembly (Option)111
Installing Transaxle Assembly (Option)112
Ptc (Push-To-Connect) Fittings113
Making a Connection113
Disconnecting114
Removing Vacuum Fan114
Installing Vacuum Motor115
Removing Carbon Brushes116
Installing Carbon Brushes116
Removing Water Solenoid (T300E Shown)117
Installing Water Solenoid118
Adjusting Water Solenoid (T300E Only)119
Control Modules121
Removing Machine Control Module (Option)121
Installing Control Module122
Removing I-Drive Module (Option)122
Installing I-Drive Module (Option)123
Removing Onboard Battery Charger (Option)123
Installing Onboard Battery Charger124
Removing Interface Module125
Installing Interface Module125
Removing Bail Switch, Speed Potentiometer, or Directional Switch126
Installing Bail Switch, Speed Potentiometer, or Directional Switch128

Tennant T300e - Service Information Manual

Table of Contents

Other manuals for Tennant T300e

Related product manuals