Trane Force Flo Cabinet Heater - Table of Contents

UNT-SVX07E-EN 3
Table of Contents
Warnings, Cautions and Notices . . . . . . . . . . 2
Model Number Descriptions . . . . . . . . . . . . . . 7
UniTrane™ Fan Coil/ Force Flo™ Cabinet
Heater
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
UniTrane™ Fan Coil Low Vertical Model . 10
General Information . . . . . . . . . . . . . . . . . . . . 12
Pre-Installation . . . . . . . . . . . . . . . . . . . . . . . . . 13
Receiving and Handling . . . . . . . . . . . . . . . 13
Inspection . . . . . . . . . . . . . . . . . . . . . . . . . 13
Packaging/Shipping . . . . . . . . . . . . . . . . . 13
Identification . . . . . . . . . . . . . . . . . . . . . . . 13
Handling . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Receiving Checklist . . . . . . . . . . . . . . . . . 13
Jobsite Storage . . . . . . . . . . . . . . . . . . . . . . 13
Site Preparation . . . . . . . . . . . . . . . . . . . . . . 14
Dimensions and Weights . . . . . . . . . . . . . . . . 15
Service Clearances . . . . . . . . . . . . . . . . . . . . 15
Component Data . . . . . . . . . . . . . . . . . . . . . 16
Available Models . . . . . . . . . . . . . . . . . . . . . 17
Model A Vertical Concealed . . . . . . . . . . 18
Model B Vertical Cabinet . . . . . . . . . . . . . 20
Model C Horizontal Concealed . . . . . . . . 22
Model D Horizontal Cabinet . . . . . . . . . . 24
Model E Horizontal Recessed . . . . . . . . . 26
Model F Vertical Wall Hung Cabinet . . . . 28
Model H Vertical Recessed . . . . . . . . . . . 30
Model J Vertical Slope Top Cabinet . . . . 32
Model K Low Vertical Concealed . . . . . . 34
Model L Low Vertical Cabinet . . . . . . . . . 36
Model M Inverted Vertical Cabinet . . . . . 38
Model N Inverted Vertical Recessed . . . . 40
Mode P Compact Concealed . . . . . . . . . . 42
Coil Connections . . . . . . . . . . . . . . . . . . . . . 43
Fan Coil Vertical Units . . . . . . . . . . . . . . . 43
Fan Coil Horizontal Units . . . . . . . . . . . . . 44
Force Flo Vertical Units . . . . . . . . . . . . . . 45
Force Flo Horizontal and Inverted Units . 46
Fresh Air Opening Locations . . . . . . . . . . . 47
Horizontal Units . . . . . . . . . . . . . . . . . . . . 47
Vertical Units . . . . . . . . . . . . . . . . . . . . . . .48
Wall Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49
Projection Panel . . . . . . . . . . . . . . . . . . . . . . .50
Installation—Mechanical . . . . . . . . . . . . . . . . .51
Installation Checklist . . . . . . . . . . . . . . . . . . .51
Installing the Unit . . . . . . . . . . . . . . . . . . . . .52
Vertical Units . . . . . . . . . . . . . . . . . . . . . . .52
Horizontal Units . . . . . . . . . . . . . . . . . . . . .52
Cabinet Units . . . . . . . . . . . . . . . . . . . . . . .53
Recessed Units . . . . . . . . . . . . . . . . . . . . . .53
Duct Connections . . . . . . . . . . . . . . . . . . . . . .54
Ductwork Recommendations . . . . . . . . . .54
Coil Piping and Connections . . . . . . . . . . . . . .55
Factory-Installed Piping Packages . . . . . . .55
Hydronic Coil Piping . . . . . . . . . . . . . . . . . . .56
Connecting Field Piping to Coil . . . . . . . . .56
Water Piping Connections . . . . . . . . . . . . . .56
Connecting to Factory Piping . . . . . . . . . .56
Condensate Drain Connections . . . . . . . . . .56
Condensate Overflow Detection Device . .57
Automatic Changeover Sensor . . . . . . . . .57
Venting the Hydronic Coil . . . . . . . . . . . . .58
External Insulating Requirements . . . . . . . .58
Balancing Manual Circuit Setter Valve . . . .58
Installation - Zone Sensors . . . . . . . . . . . . . . .61
Zone Sensor Options . . . . . . . . . . . . . . . . . .61
ZN010 Controller Options . . . . . . . . . . . . .61
ZN510, ZN520, UC400 Controller Options 61
Installation Considerations . . . . . . . . . . . . .62
Location . . . . . . . . . . . . . . . . . . . . . . . . . . .62
Placement . . . . . . . . . . . . . . . . . . . . . . . . . .63
Height Requirements . . . . . . . . . . . . . . . . .63
Mounting Surfaces . . . . . . . . . . . . . . . . . . .63
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . .63
Fan Mode Switch . . . . . . . . . . . . . . . . . . . .63
Wired Zone Sensor . . . . . . . . . . . . . . . . . .64
Wireless Zone Sensors . . . . . . . . . . . . . . .64
Receivers . . . . . . . . . . . . . . . . . . . . . . . . . . .65