SAFETY
Safety - 19
KN4500 Safety Procedures
• Power unit hydraulic system may contain stored energy. Before performing maintenance or repairs on
the auxiliary hydraulic circuit, remove attachments, engage the park brake, disengage weight transfer
system (if equipped), shut off engine, and remove the ignition key.
• Weight transfer spring may contain stored energy. Always disengage the weight transfer system (if
equipped) before performing maintenance or repairs on the weight transfer system, the front hitch, or
the lift hydraulics.
Roll Over Protective Structure (ROPS)
WARNING
Alterations or modifi cations to this machine and/or
the ROPS structure can reduce safety and could
cause damage to the machine. Do not alter the
ROPS. Do not alter any other safety devices.
WARNING
Keep the ROPS locked in the upright position and
the seat belt securely fastened during operation.
Failure to do so could result in serious injury or
loss of life.
Your power unit is equipped with a Roll-Over Protective Structure (ROPS). This ROPS was tested in accor-
dance with OSHA 1928.51 (ROPS) and ISO 6683 (Seat Belt Anchorage). This ROPS is certifi ed for use on
a Ventrac 4500 with a maximum GVW of 4,000 pounds (1818 Kg).
• ROPS certifi cation applies only when the roll bar is locked in the upright position.
• Alterations to the ROPS structure are not permitted.
• Lower the roll bar only when absolutely necessary and raise the roll bar to the upright position as soon
as clearance allows.
• Always wear the seat belt when the roll bar is locked in the upright position.
• Do not wear a seat belt when the roll bar has been lowered to the down position.
• If any part of this ROPS experiences structural damage, the entire ROPS must be replaced.
• Inspect the seat belt for wear or damage before use. Failure to inspect or maintain the seat belt can
cause injury or loss of life.
Operator Access System
• The operator access system is on the left side of the power unit. Mount and dismount the 4500 only on
the left side of the power unit.
WARNING
The engine exhaust from this product contains
chemicals known to the State of California to cause
cancer, birth defects, or other reproductive harm.
CALIFORNIA PROPOSITION 65
Battery Warning
Battery posts, terminals, and related accessories
contain lead and lead compounds, chemicals
known to the State of California to cause cancer
and reproductive harm. Wash hands after handling!
CALIFORNIA PROPOSITION 65
Diesel Exhaust Warning
Diesel engine exhaust and some of its constituents
are known to the State of California to cause
cancer, birth defects, or other reproductive harm.
To Next Page
Loading...
