Ventrac LE3200 - Maintenance Schedule

Service - 41
Maintenance Schedule
3200 - Vanguard 23.6 hp Engine
Maintenance
Schedule
#
o
f
L
o
c
a
t
i
o
n
s
#
o
f
P
u
m
p
s
A
S
N
E
E
D
E
D
A
f
t
e
r
F
i
r
s
t
2
5
H
r
s
.
D
a
i
l
y
A
t
5
0
H
o
u
r
s
A
t
1
0
0
H
o
u
r
s
A
t
1
5
0
H
o
u
r
s
A
t
2
0
0
H
o
u
r
s
A
t
2
5
0
H
o
u
r
s
A
t
3
0
0
H
o
u
r
s
A
t
3
5
0
H
o
u
r
s
A
t
4
0
0
H
o
u
r
s
A
t
4
5
0
H
o
u
r
s
A
t
5
0
0
H
o
u
r
s
A
t
5
5
0
H
o
u
r
s
A
t
6
0
0
H
o
u
r
s
A
t
6
5
0
H
o
u
r
s
A
t
7
0
0
H
o
u
r
s
A
t
7
5
0
H
o
u
r
s
A
t
8
0
0
H
o
u
r
s
A
t
8
5
0
H
o
u
r
s
A
t
9
0
0
H
o
u
r
s
A
t
9
5
0
H
o
u
r
s
A
t
1
0
0
0
H
o
u
r
s
Y
e
a
r
l
y
5
Y
e
a
r
s
o
r
2
0
0
0
H
r
s
.
Grease & Lubrication: See Lubrication Section
Front Hitch
21
9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9
Lift Cylinder
21
9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9
Center Pivot
11
9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9
Steering Cylinder End
21
9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9
Lower Connector Link
21
9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9
Seat Rails
2#
9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9 9
9
9 9 9 9 9 9 9 9 9 9 9
9
** **
9
**
9
**
9
**
9
**
9
9 9
**
9
9 9 9
9 9
9
9
9
9
9 9
9
9
9
9 9 9 9 9 9
9 9 9 9 9 9 9 9 9 9
9 9 9 9 9 9 9 9 9 9
9 9 9 9 9 9 9 9 9 9
^ Grease Until Fresh Grease is visible
# Silicon Based Spray Lubricant
! Consult Engine Owner's Manual for engine oil information and complete servicing information
@ Optional Equipment
* If heavy load, high temperature, or dusty condition service intervals are not specified, Ventrac recommends servicing more frequently at 1/2 the standard service interval.
** Operation in severe conditions may require more frequent service intervals.
Check Front/Rear Connector Link Bolts.
Torque to 140 ft-lbs
Check Front Hitch Pivot Bolts. Torque to
75 ft-lbs
Check Wheel Lug Nuts. Torque to 85 ft-lbs
Check Steering Cylinder Bolts. Torque to
140 ft-lbs
Inspect Belts, Fuel Lines, and Hydraulic
Lines
Check Tire Pressure.
Inspection
Inspect for Loose, Missing, or Worn
Components
Replace Light Bulbs
Clean Battery Terminals & Compartment
Inspect Parking Brake Tension
Electrical
Change Hydraulic Oil and Filter
Parking Brake
Hydraulic System
Check Hydraulic Oil Level
Replace Fuel Filter
Drain Water & Sediment from Fuel Tank
Replace Safety Air Filter
@
Clean Radiator, Engine Compartment,
Engine, & Outer Hood Screens
Inspect Primary Air Filter
Replace Primary Air Filter
Change Engine Oil & Filter
!
Service Cooling System
Consult Engine Owner's Manual
Engine
!
Check Engine Oil Level
Grease & Lubrication: See Lubrication Section
SERVICE