Home
WEICHAI
Engine
WD10
WEICHAI WD10 Manual
5
of 1
of 1 rating
75 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
23
※
Adjust the valve clearance as step B
※
Loosen
the
xing
nut of
rocker
arm,
adjust the
clearance
by
gauge
then tighten the nut again.
※
T
ool: 13 mm sleeve wrench
※
Install the gasket and cylinder head cover
※
The tightening torque of bolt is 23 N•m (recommended)
Step B
24
26
Table of Contents
Table of Contents
1
Chapter I Maintenance for WD615/WD10/WD618/WD12 Diesel Engines
3
Daily Maintenance
5
Periodic Maintenance
7
Maintenance Interval
8
Maintenance Contents
12
Replacement of Oil and Oil Filter
15
Replace Fuel Filter
18
Check Air Filter Element
19
Check and Adjust Valve Clearance
21
Check and Adjust Fuel Supply Advance Angle
26
Chapter II Key Points about Assembling or Disassembling WD615 Diesel
28
Engines
28
Assemble Injection Nozzle, Camshaft and Cylinder Liner
28
Assemble Injection Nozzle
28
Assemble Camshaft
28
Assemble Cylinder Liner
29
Pre-Assemble & Assemble Crankshaft
31
Assembling Steps (1)
31
Assembling Steps (2)
32
Assemble Cylinder Body
33
Pre-Assemble & Assemble Connecting Stick and Piston
34
The Assembly of the Timing Gear Housing
38
The Assembly of Flywheel Housing and Flywheel
41
The Assembly of Flywheel Housing
41
The Assembly of Flywheel
41
The Assembly of Front Oil Seal and Camshaft Timing Gear
42
Tightening Torque and Tightening Method of Main Bolts of Diesel Engine
44
Chapter III Introduction of Fault Case for WD615/618 Diesel Engine
46
Diesel Engine Starts Hard
46
Case Description about Diesel Engine Cannot be Started (1)
48
Case Description about Diesel Engine Cannot be Started (2)
50
Stop Soon after Starting
52
Insufficient Output
54
Case Description about Insufficient Output (1)
55
Case Description about Insufficient Output (2)
56
Case Description about Insufficient Output (3)
57
Fuel Consumption Is too High
59
Black Smoke Exhaust
61
And Exhaust Pipe
64
Oil Is Gathered in Inlet and Exhaust Vents of Turbocharger and Inlet
65
Lub-Oil Pressure Is too Low
67
Case Description about Lub-Oil Pressure Is too Low (1)
68
Case Description about Lub-Oil Pressure Is too Low (2)
69
Cooling Water Temperature Is too High
72
The Oil Mixed with the Water
75
Other manuals for WEICHAI WD10
Service Manual
163 pages
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the WEICHAI WD10 and is the answer not in the manual?
Ask a question
WEICHAI WD10 Specifications
General
Brand
WEICHAI
Model
WD10
Category
Engine
Language
English
Related product manuals
WEICHAI WD12
75 pages
WEICHAI WD615
75 pages
WEICHAI WD618
75 pages
WEICHAI WP12
57 pages
WEICHAI WP10
33 pages
WEICHAI WP13
33 pages
WEICHAI WP6GNA
82 pages
WEICHAI WP10.270
49 pages
WEICHAI WP10.336
49 pages
WEICHAI WP12C500
17 pages
WEICHAI WP13.530
38 pages
WEICHAI WP06 Series
33 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
