Whirlpool 27' - Table of Contents

III
TABLE OF CONTENTS
INTRODUCTION.................................................................................................................. II
TABLE OF CONTENTS ...................................................................................................... III
SECTION ONE
GENERAL INFORMATION
Electric Requirements .................................................................................................. 1
Exhaust Requirements for Electric and Gas Dryers .................................................. 5
Gas Requirements for Gas Dryers .............................................................................. 6
Recessed and Closet Installation Instructions........................................................... 8
SECTION TWO
THEORY OF OPERATION
Controls and Cycles....................................................................................................................9
Electronic Dryer Control...........................................................................................................10
Heated Air Circulation...............................................................................................................11
SECTION THREE
COMPONENT ACCESS .................................................................................................... 13
Removing the Console ..........................................................................................................13
Removing the Timer ..............................................................................................................14
Removing the Clean touch Switch Assembly ........................................................................14
Removing the Push to Start Button .......................................................................................14
Removing the Buzzer ............................................................................................................14
Removing the Electronic Control Board ................................................................................14
Removing the Dryer Top........................................................................................................14
Replacing the Drum Lamp.....................................................................................................15
Removing the Door Switch ....................................................................................................15
Removing the Toe Panel .......................................................................................................15
Removing the Blower Wheel .................................................................................................16
Replacing the Blower Housing ..............................................................................................16
Replacing the Motor ..............................................................................................................17
Replacing the Operating Thermostat and Bias Heater..........................................................17
Replacing the Thermal Fuse .................................................................................................17
Replacing the Heating Element .............................................................................................18
Replacing the Burner Assembly ............................................................................................18
Replacing the High Limit Thermostat and Thermal Cutoff ....................................................18
Replacing the Heat Duct Assembly .......................................................................................18
Removing the Dryer Door......................................................................................................19
Removing the Front Panel.....................................................................................................19
Removing the Belt and Drum ................................................................................................20
Replacing the Front Support Rollers and Shafts ...................................................................20
Replacing the Grille Assembly ..............................................................................................20
Removing the Rear Bulkhead Assembly ...............................................................................21
Reattaching the Rear Bulkhead ............................................................................................21